Skip to main content Accessibility help

Rolled Rye Mulch for Weed Suppression in Organic No-Tillage Soybeans

  • Adam N. Smith (a1), S. Chris Reberg-Horton (a1), George T. Place (a1), Alan D. Meijer (a2), Consuelo Arellano (a3) and J. Paul Mueller (a1)...


Rising demand for organic soybeans and high price premiums for organic products have stimulated producer interest in organic soybean production. However, organic soybean producers and those making the transition to organic production cite weed management as their main limitation. Current weed management practices heavily rely on cultivation. Repeated cultivation is expensive and has negative consequences on soil health. Research is needed to improve organic reduced tillage production. Rye cover crop mulches were evaluated for weed suppression abilities and effects on soybean yield. Experiments were planted in 2008 and 2009 at three sites. Rye was planted in the fall of each year and killed at soybean planting with a roller/crimper or flail mower, creating a thick weed-suppressing mulch with potential allelopathic properties. The mulch was augmented with one of three additional weed control tactics: preemergence (PRE) corn gluten meal (CGM), postemergence (POST) clove oil, or postemergence high-residue cultivation. Roll-crimped and flail-mowed treatments had similar weed suppression abilities at most sites. There were no differences between CGM, clove oil, or cultivation at most sites. Sites with rye biomass above 9,000 kg ha−1 of dry matter provided weed control that precluded soybean yield loss from competition. In Goldsboro 2008, where rye biomass was 10,854 kg ha−1 of dry matter, the soybean yield in the rolled rye treatment was not significantly different from the weed-free treatment, yielding at 2,190 and 2,143 kg ha−1, respectively. Likewise, no difference in soybean yield was found in Plymouth 2008 with a rye biomass of 9,256 kg ha−1 and yields of 2,694 kg ha−1 and 2,809 kg ha−1 in the rolled rye and weed-free treatments, respectively. At low rye biomass levels (4,450 to 6,606 kg ha−1), the rolled rye treatment soybean yield was 628 to 822 kg ha−1 less than the weed-free treatment. High rye biomass levels are critical to the success of this production system. However, high rye biomass was, in some cases, also correlated with soybean lodging severe enough to cause concern with this system.


Corresponding author

Corresponding author's Email:


Hide All
Arshad, M. A., Schnitzer, M., Anger, D. A., and Ripmeester, D. A. 1990. Effects of till vs. no-till on the quality of soil organic matter. Soil Biol. BioChem. 22:595599.
Ashford, D. L. and Reeves, D. W. 2003. Use of a mechanical roller-crimper as an alternative kill method for cover crops. Am. J. Altern. Agric. 18(1):3745.
Bainard, L. D., Isman, M. B., and Upadhyaya, M. K. 2006. Phytotoxicity of clove oil and its primary constituent eugenol and the role of leaf epicuticular wax in the susceptibility to these essential oils. Weed Sci. 54:833837.
Barnes, J. P. and Putnam, A. R. 1983. Rye residues contribute weed suppression in no-tillage cropping systems. J. Chem. Ecol. 9:10451057.
Barnes, J. P. and Putnam, A. R. 1987. Role of benzoxazinones in allelopathy by rye (Secale cereale L.). J. Chem. Ecol. 13:889906.
Beale, O. W., Nutt, G. B., and Peele, T. C. 1955. The effects of mulch tillage on runoff, erosion, soil properties, and crop yields. Soil Sci. Soc. Am. J. 19:244247.
Bingaman, B. R. and Christians, N. E. 1995. Greenhouse screening of corn gluten meal as a natural control product for broadleaf and grass weeds. Hortscience. 30:12561259.
Boyd, N. S. and Brennan, E. B. 2006. Burning nettle, common purslane, and rye response to a clove oil herbicide. Weed Technol. 20:646650.
Cavigelli, M. A., Teasdale, J. R., and Conklin, A. E. 2008. Long-term agronomic performance of organic and conventional field crops in the mid-Atlantic region. Agron. J. 100:785794.
Christians, N. E. 1993. The use of corn gluten meal as a natural preemergence weeds control in turf. Chapter 35. Int. Turfgrass Soc. Res. J. 7:284290.
Coleman, D. C., Crossley, D. A., and Hendrix, P. F. 2004. Fundamentals of Soil Ecology. 2nd ed. Elsevier, Burlington, MA: 386 p.
Creamer, N. G. and Dabney, S. M. 2002. Killing cover crops mechanically: Review of recent literature and assessment of research results. Am. J. Altern. Agr. 17(1):3240.
Creamer, N. G., Plassman, B., Bennett, M. A., Wood, R. K., Stinner, B. R., and Cardina, J. 1995. A method for mechanically killing cover crops to optimize weed suppression. Am. J. Altern. Agr. 10(4):157162.
Davis, A. S. 2010. Cover-crop roller-crimper contributes to weed management in no-till soybean. Weed Sci. 58:300309.
Ferguson, J. J. 2004. Evaluation of organic herbicides. Hortscience. 39:876 p.
Griggs, T. C. 2006. Fall and winter spring forage production and quality of winter cereals seeded at three fall dates. Forage and Grazinglands. DOI: . Accessed: March 9, 2010.
Hargrove, W. L. 1990. Role of conservation tillage in sustainable agriculture. Pages 2832 in Mueller, J. P., and Wagger, M. G., eds. Conservation Tillage for Agriculture in the 1990s: Proceedings of the 1990 Southern Regional Conservation Tillage Conference. Raleigh, NC North Carolina State University.
Hunt, D. 1977. Farm Power and Machinery Management—Laboratory Manual and Workbook. 7th ed. Ames, IA Iowa State University Press. 365 p.
Kornecki, T. S., Price, A. J., Raper, R. L., and Arriaga, A. J. 2009. New roller crimper concepts for mechanical termination of cover crops in conservation agriculture. Renewable Agric. Food Syst. 24:165173.
Liebl, R., Simmons, F. W., Wax, L. M., and Stoller, E. W. 1992. Effect of rye (Secale cereale) mulch on weed control and soil moisture in soybean (Glycine max). Weed Technol. 6:838846.
Liebman, M. and Gallandt, E. 1997. Many little hammers: ecological approaches for management of crop-weed interactions. Page 78 in Jackson, L. E., ed. Agricultural Ecology. San Diego, CA Academic.
Lu, Y. C., Watkins, K. B., Teasdale, J. R., and Adbul-Baki, A. A. 2000. Cover crops in sustainable food production. Food Rev. Int. 16:121157.
Masiunas, J. B., Weston, L. A., and Weller, S. C. 1995. The impact of rye cover crops on weed populations in the tomato cropping system. Weed Sci. 43:318323.
Mirsky, S., Curran, W. S., Mortensen, D. A., Ryan, M. R., and Shumway, D. 2009. Control of cereal rye with a roller/crimper as influenced by cover crop phenology. Agron. J. 101:15891596.
Mohler, C. L. and Teasdale, J. R. 1993. Response of weed emergence to rate of Vicia villosa Roth and Secale cereale L. residue. Weed Res. 33:487499.
Moore, M. J., Gillespie, T. J., and Swanton, C. J. 1994. Effect of cover crop mulches on weed emergence, weed biomass, and soybean (Glycine max) development. Weed Technol. 8:512518.
[NC Ag Census] North Carolina Agricultural Census. 2007. Table 48: Organic Agriculture.,_Chapter_1_State_Level/North_Carolina/st37_1_048_048.pdf. Accessed: November 11, 2009.
[OTA] Organic Trade Association. 2008. Organic Facts. Accessed: June 2, 2010.
Paustian, K., Cole, C. V., Sauerbeck, D., and Sampson, N. 1998. CO2 mitigation by agriculture: an overview. Clim. Change. 41:14801573.
Ranells, N. N. and Wagger, M. G. 1996. Nitrogen release from grass and legume cover crops monocultures and bicultures. Agron. J. 88:777782.
Raper, R. L., Reeves, D. W., Schwal, E. B., and Burmester, C. H. 2000. Reducing soil compaction of Tennessee Valley soils in conservation tillage systems. J. Cotton Sci. 4:8490.
Reeves, D. W., Price, A. J., and Patterson, M. G. 2005. Evaluation of three winter cereals for weed control in conservation-tillage nontransgenic cotton. Weed Technol. 19:731736.
Roberts, C. J., Lynch, D. H., Voroney, R. P., Martin, R. C., and Juurlink, S. D. 2008. Nutrient budgets of Ontario organic dairy farms. Can. J. Soil Sci. 88(1):107114.
Rodale Institute. 2009. No-Till Revolution. Accessed: March 15, 2010.
Rosecrance, R. C., McCarty, G. W., Shelton, D. R., and Teasdale, J. R. 2000. Denitrification and N mineralization from hairy vetch (Vicia villosa Roth) and rye (Secale cereale L.) cover crop monocultures and bicultures. Plant Soil. 227:283290.
Ryan, M. R., Smith, R. G., Mortensen, D. A., Teasdale, J. R., Curran, W. S., Seidel, R., and Shumway, D. L. 2009. Weed–crop competition relationships differ between organic and conventional cropping systems. Weed Res. 49:572580.
[SAS] Statistical Analysis Systems. 2006. Procedures Guide. Release 9.1.3. 2nd ed. Cary NCSAS Institute.
Six, J., Elliott, E. T., and Paustian, K. 1999. Aggregate and soil organic matter dynamics under conventional and no-tillage systems. Soil Sci. Soc. Am. J. 63:13501358.
Snapp, S. S., Swinton, S. M., Labarta, R., Mutch, D., Black, J. R., Leep, R., Nyiraneza, J., and O'Neil, K. 2005. Evaluating cover crops for benefits, costs, and performance within cropping system niches. Agron. J. 97:322332.
Teasdale, J. R. and Mohler, C. L. 1993. Light transmittance, soil temperature, and soil moisture under residue of hairy vetch and rye. Agron. J. 85:673680.
Teasdale, J. R. and Mohler, C. L. 2000. The quantitative relationship between weed emergence and the physical properties of mulches. Weed Sci. 48:385392.
Tworkoski, T. 2002. Herbicide effects of essential oils. Weed Sci. 50:425431.
USDA. 2009a. North Carolina Grain Prices Paid to Producers by Location. North Carolina Department of Agriculture Market News. Accessed: January 5, 2010.
USDA. 2009b. National Organic Grain and Feedstuffs. USDA Livestock and Grain Market News. Accessed: January 5, 2010.
Walz, E. 1999. Third Biennial National Organic Farmers' Survey. Santa Cruz, CA Organic Farming Research Foundation. 126 p.
Webber, C. L. III, Shrefler, J. W., Brandenberger, L. P., Taylor, M. J., and Boydston, R. A. 2009. Organic herbicide update. Pages 237239 in Proceedings of the 28th Horticulture Industries Show. Ft. Smith, AR.
Weersink, A., Walker, M., Swanton, C., and Shaw, J. E. 1992. Costs of conventional and conservation tillage systems. J. Soil Water Conserv. 47:328334.
Weston, L. A. 1990. Cover crop and herbicide influence on row crop seedling establishment in no-tillage culture. Weed Sci. 38:166171.
Weston, L. A. 1996. Utilization of allelopathy for weed management in agroecosystems. Agron. J. 88:860866.
Wossink, G. A. A. and Kuminoff, N. 2002. Organic Agriculture in North Carolina. North Carolina Cooperative Extension Service: North Carolina State Economist. September/October.14.
Yenish, J. P., Worsham, A. D., and York, A. C. 1996. Cover crops for herbicide replacement in no-tillage corn (Zea mays). Weed Technol. 10:815821.



Full text views

Total number of HTML views: 0
Total number of PDF views: 0 *
Loading metrics...

Abstract views

Total abstract views: 0 *
Loading metrics...

* Views captured on Cambridge Core between <date>. This data will be updated every 24 hours.

Usage data cannot currently be displayed