Hostname: page-component-76fb5796d-45l2p Total loading time: 0 Render date: 2024-04-26T22:25:52.270Z Has data issue: false hasContentIssue false
  • English
  • Français

Polystyrene thin films treatment under DC pulsed discharges conditions in nitrogen-argon and oxygen-argon mixtures

Published online by Cambridge University Press:  15 February 2002

F. Clément ,
B. Held  and
N. Soulem
F. Clément
Affiliation:
Laboratoire d'Électronique, des Gaz et des Plasmas, Université de Pau, 64000 Pau, France
B. Held*
Affiliation:
Laboratoire d'Électronique, des Gaz et des Plasmas, Université de Pau, 64000 Pau, France
N. Soulem
Affiliation:
Laboratoire d'Électronique, des Gaz et des Plasmas, Université de Pau, 64000 Pau, France
*
bernard.held@univ-pau.fr
Get access

Abstract

This paper is the third of a trilogy [16,75] devoted to polystyrene thin film treatment under DC pulsed discharges conditions. In order to study the wettability variations ($\Delta \theta/\theta_i$) of the surface, N2-Ar or O2-Ar mixtures are used. The experimental conditions are close to the best running conditions deduced from [16,75]. The pressure is varied from 1 mbar to 10 mbar and the mixture proportion from 0% to 100%. The importance of metastable states is pointed out. Reaction processes in the plasma and on the polystyrene surface are proposed in order to explain the surface activation and the formation of chemical bonds with nitrogen or oxygen. The best running conditions are reached when the generator frequency equals 500 Hz for a pressure about 4 mbar in nitrogen and 10 mbar in oxygen, whatever the gas mixture composition is. The wettability is better with oxygen than with nitrogen and the best value is reached for a duration time shorter in oxygen than in nitrogen. The minimum of treatment time necessary to reach the $\Delta \theta/\theta_i$ plateau value depends on the mixture composition.

Keywords

Type
Research Article
Information
The European Physical Journal - Applied Physics , Volume 17 , Issue 2 , February 2002 , pp. 119 - 130
Copyright
© EDP Sciences, 2002

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Briggs, D., Rance, D.G., Kendall, C.R., Blythe, A.R., Polymer 21, 895 (1980). CrossRef
Tutsui, K., Iwata, A., Ikeda, S., J. Coatings Technol. 61, 65 (1989).
Amouroux, J., Arefi, F., J. Fr. Electrotherm. 37, 47 (1989).
Amouroux, J., Arefi, F., Inf. Chim. 309, 169 (1989).
J.E. Klemberg-Sapieha, L. Martinu, O.M. Küttel, M.R. Wertheimer, Metallized Plastics 2, edited by K.L. Mittal (Plennum Press, 1991), pp. 315-329.
F. Clouet, Dépôt et gravure chimique par plasma, CIP91, Société Française du Vide (1991).
Liston, E.M., Martinu, L., Wertheimer, M.R., J. Adhesion Sci. Technol. 7, 1091 (1993). CrossRef
Tatoulian, M., Arefi-Khonsari, F., Mabille-Rouger, I., Amouroux, J., Gheorgiu, M., Bouchier, D., J. Adhesion Sci. Technol. 9, 923 (1995). CrossRef
Wertheimer, M.R., Thomas, H.R., Perri, M.J., Klemberg-Sapieha, J.E., Martinu, L., Pure Appl. Chem. 68, 1047 (1996). CrossRef
Chan, C.M., Ko, T.M., Hiraoka, H., Surf. Sci. Rep. 24, 1 (1996). CrossRef
Denes, F., TRIP 5, 23 (1997).
Held, B., Inf. Polym. 25, 2 (1997).
D. Sage, E . Espuche, J.P. Soulier, Journées d'Études Plasmas Surfaces Adhésion (3-4/12/1998, Toulouse, France).
Liesegang, J., Senn, B.C., Pigram, P.J., Kang, E.T., Tan, K.L., Neoh, K.G., Surf. Interface Anal. 28, 20 (1999). 3.0.CO;2-N>CrossRef
Clément, F., Soulem, N., Held, B., Le Vide 294, 513 (1999).
Clément, F., Held, B., Soulem, N., Spyrou, N., Eur. Phys. J. AP 13, 67 (2001). CrossRef
Gerenser, L.J., J. Adhesion Sci. Technol. 1, 303 (1987). CrossRef
Nakayama, Y., Takahagi, T., Soeda, F., J. Polym. Sci. Part A: Polymer Chemistry 26, 559 (1988). CrossRef
Lub, J., van Vroonhoven, F.C.B.M., Bruninx, E., Benninghoven, A., Polymer 30, 40 (1989). CrossRef
Foerch, R., McIntyre, N.S., Sodhi, R.N.S., J. Appl. Polym. Sci. 40, 1903 (1990). CrossRef
Foerch, R., McIntyre, N.S., Hunter, D.H., J. Polym. Sci. Part A: Polymer Chemistry 28, 803 (1990). CrossRef
Foerch, R., Johnson, D., Surf. Sci. Interface Anal. 17, 847 (1991). CrossRef
Foerch, R., Beamson, G., Briggs, D., Surf. Interface Anal. 17, 842 (1991). CrossRef
Klemberg-Sapieha, J.E., Küttel, O.M., Martinu, L., Wertheimer, M.R., J. Vac. Sci. Technol. A9, 2975 (1991). CrossRef
Foerch, R., Hunter, D.H., J. Polym. Sci. Part A: Polymer Chemistry 30, 279 (1992). CrossRef
Foerch, R., Kill, G., Walzak, M.J., J. Adhesion Sci. Technol. 7, 1077 (1993). CrossRef
Petrat, F.M., Wolany, D., Schwede, B.C., Wiedmann, L., Benninghoven, A., Surf. Interface Anal. 21, 274 (1994). CrossRef
Geuskens, G., Baeyens-Volant, D., Delaunois, G., Lu-Vinh, Q., Piret, W., David, C., Eur. Polym. J. 14, 291 (1978). CrossRef
Clark, D.T., Dilks, A., J. Polym. Sci.: Polymer Chemistry Edition 17, 957 (1979).
Iwamoto, G.K., King, R.N., Andrade, J.D., Am. Chem. Soc. 24, 405 (1981).
Mance, A.M., Waldo, R.A., Dow, A.A., J. Electrochem. Soc. 136, 1667 (1989). CrossRef
Namatsu, H., J. Electrochem. Soc. 136, 2676 (1989). CrossRef
Golub, M.A., Wydeven, T., Cormia, R.D., Polymer 30, 1571 (1989). CrossRef
Wydeven, T., Golub, M.A., Lerner, N.R., J. Appl. Polym. Sci. 37, 3343 (1989). CrossRef
Foerch, R., McIntyre, N.S., Hunter, D.H., J. Polym. Sci. Part A: Polymer Chemistry 28, 193 (1990). CrossRef
Foerch, R., McIntyre, N.S., Hunter, D.H., Kunstst. Ger. Plast. 81, 3 (1991).
Occiello, E., Morra, M., Morini, G., Garbassi, F., Humphrey, P., J. Appl. Polym. Sci. 42, 551 (1991). CrossRef
Strobel, M., Lyons, C.S., Strobel, J.M., Kapaun, R.S., J. Adhesion Sci. Technol. 6, 429 (1992). CrossRef
Strobel, M., Walzak, M.J., Hill, J.M., Lin, A., Karbashewski, E., Lyons, C.S., J. Adhesion Sci. Technol. 9, 365 (1995). CrossRef
Shahidzadeh-Ahmadi, N., Chehimi, M.M., Arefi-Khonsari, F., Foulon-Belkacemi, N., Amouroux, J., Delamar, M., Colloids and Surf. 105, 277 (1995). CrossRef
Kill, G., Hunter, D.H., McIntyre, N.S., J. Polym. Sci. Part A: Polymer Chemistry 34, 2299 (1996). 3.0.CO;2-S>CrossRef
Arefi-Khonsari, K., Placinta, G., Amouroux, J., Popa, G., Eur. Phys. J. AP 4, 193 (1998). CrossRef
Moisan, M., Barbeau, C., Claude, R., Ferreira, C.M., Margot, J., Paraszczak, J., Sà, A.B., Sauvé, G., Wertheimer, M.R., J. Vac. Sci. Technol. B9, 8 (1991). CrossRef
P. Mérel, M. Tabbal, M. Chaker, M. Moisan, A. Ricard, A high flux source of N atoms based on a N2 HF discharge, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 1, pp. 168-169.
Guiberteau, E., Bonhomme, G., Hugon, R., Henrion, G., Surface and Coatings Technol. 97, 552 (1997). CrossRef
Dengra, A., Ballesteros, J., Hernandez, M.A., Colomer, V., J. Appl. Phys. 68, 5507 (1990). CrossRef
Markovic, V.L., Gocic, S.R., Radovic, M.K., Eur. Phys. J. AP 6, 303 (1999). CrossRef
Markovic, V.Lj., Pejovic, M.M., Petrovic, Z.Lj., J. Phys. D: Appl. Phys. 27, 979 (1994). CrossRef
Markovic, V.Lj., Petrovic, Z.Lj., Pejovic, M.M., Plasma Sources Sci. Technol. 6, 240 (1997). CrossRef
Markovic, V.Lj., Gocic, S.R., Radovic, M.K., Eur. Phys. J. AP 6, 303 (1999). CrossRef
A. Ricard, Plasmas réactifs (Société Française du Vide, 1995).
Ricard, A., J. Phys. D: Appl. Phys. 30, 2261 (1997). CrossRef
G. Cartry, L. Magne, G. Cernogora, M. Touzeau, M. Vialle, Relaxation of excited states in oxygen nitrogen mixtures in a low pressure afterglow, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 2, pp. 71-72.
Maier, W.B., J. Chem. Phys. 61, 3459 (1974). CrossRef
Cernogora, G., Ferreira, C.M., Hochard, L., Touzeau, M., Loureiro, J., J. Phys. B: At. Mol. Phys. 17, 4429 (1984). CrossRef
Brunet, H., Rocca-Serra, J., J. Appl. Phys. 57, 1574 (1985). CrossRef
Capitelli, M., Gorse, C., Ricard, A., Topics Current Phys. 39, 315 (1986). CrossRef
Ricard, A., Henrion, G., Michel, H., Gantois, M., Pure Appl. Chem. 60, 747 (1988). CrossRef
Ricard, A., Rev. Phys. Appl. 24, 251 (1989). CrossRef
Loureiro, J., Ricard, A., J. Phys. D: Appl. Phys. 26, 163 (1993). CrossRef
Longo, S., Hassouni, K., Iasilloo, D., Capitelli, M., J. Phys. III France 7, 707 (1997). CrossRef
Gordiets, B., Ferreira, C.M., Pinhero, M.J., Ricard, A., Plasma Sources Sci. Technol. 7, 363 (1998). CrossRef
Ricard, A., Gordiets, B.F., Pinheiro, M.J., Ferreira, C.M., Baravian, G., Amorim, J., Bockel, S., Michel, H., Eur. Phys. J. AP 4, 87 (1998). CrossRef
de Souza, A.R., Digiacomo, M., Muzart, J.L.R., Nahorny, J., Ricard, A., Eur. Phys. J. AP 5, 185 (1999). CrossRef
Loiseau, J.F., Pignolet, P., Held, B., J. Phys. D: Appl. Phys. 25, 745 (1992). CrossRef
Czerwiec, T., Gavillet, J., Belmonte, T., Michel, H., Ricard, A., J. Phys. III France 6, 1205 (1996). CrossRef
T. Belmonte, T. Cserwiec, A. Ricard, H. Michel, 3D-modeling of N atom titration by NO in Ar-N2 post-discharges, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 4, pp. 66-67.
S. Bockel, D. Ablitzer, H. Michel, A. Ricard, Nitrogen active species in a microwave flowing post-discharge reactor, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 4, pp. 200-201.
Magne, L., Coitout, H., Cernogora, G., Gousset, G., J. Phys. III France 3, 1871 (1993). CrossRef
Pinheiro, M.J., Gordiets, B.F., Ferreira, C.M., Plasma Sources Sci. Technol. 8, 31 (1999). CrossRef
M. Gaillard, Effet d'une post-décharge d'oxygène en flux sur le dégraissage de surfaces métalliques, Doctorate thesis, Paul Sabatier University, Toulouse, 2000.
Gordiets, B., Ferreira, C.M., Nahorny, J., Pagnon, D., Touzeau, M., Vialle, M., J. Phys. D: Appl. Phys. 29, 1021 (1996). CrossRef
V. Zvonicek, V. Guerra, J. Loureiro, A. Talsky, M. Touzeau, Surface and volume kinetice of O(3P) atoms in a low-pressure O2-N2 microwave discharge, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 4, pp. 160-161.
G. Cartry, L. Magne, G. Cernogora, M. Touzeau, M. Vialle, Effect of wall treatment on oxygen atoms recombination, XXIII ICPIG (Toulouse, 17-22 juillet 1997) 1997, Vol. 2, pp. 70-71.
F. Clément, B. Held, N. Soulem, submitted to Eur. Phys. J. AP.
N. Soulem, Application de l'interaction laser-gaz à l'étude des régimes de fonctionnement d'une décharge électrique, Doctorate thesis, Pau University, 1996.
A.E. Ercilbengoa, Étude expérimentale des régimes de décharge continue positive dans l'azote et dans l'air pour différentes pressions, Doctorate thesis, Pau University, 1999.
J.L. Delcroix, C. Matos Ferreira, A. Ricard, Atomes et molécules métastables dans les gaz ionisés (Éditions du CNRS, 1975).
Hays, G.N., Oskam, H.J., J. Chem. Phys. 59, 1507 (1973). CrossRef
J.L. Marchand, Contribution à la modélisation du procédé de nitruration ionique, Doctorate thesis, Institut National Polytechnique de Lorraine, Nancy, 1988.
L. Petitjean, Étude d'une décharge électrique dans un mélange azote-hydrogène pour la nitruration de surfaces métalliques, Doctorate thesis, Orsay University, 1982.
Phelps, A.V., J. Phys. Chem. Ref. Data 20, 557 (1991). CrossRef
B. Rosen, Données spectroscopiques relatives aux molécules diatomiques (Pergamon Press, 1970).
M. Yousfi, N. Azzi, P. Segur, I. Gallimberti, S. Stangherlin, Electron-molecule collision cross sections and electron swarm parameters in some atmospheric gases, CPAT Toulouse, 1988.
M. Touzeau, Excitation de l'azote par les atomes métastables d'argon, Es-Science Doctorate thesis, Orsay University, 1978.