Hostname: page-component-77c89778f8-vsgnj Total loading time: 0 Render date: 2024-07-18T06:51:27.354Z Has data issue: false hasContentIssue false
  • English
  • Français

Electrical Reliability of Giant Magneto-Resistive Recording Sensors

Published online by Cambridge University Press:  10 February 2011

I-Fei Tsu ,
C. Chang  and
H. S. Edelman
C. Chang
Affiliation:
Seagate Technology, Minnesota, U.S.A
H. S. Edelman
Affiliation:
Seagate Technology, Minnesota, U.S.A
Get access

Abstract

The electrical reliability of Ta/NiMn/NiFe/Co/Cu/Co/NiFe/Ta top spin valve sensors was studied. Electrical current densities in the range of 20–50 MA/cm2 were applied at 70°C ambient temperature. The combined Joule and ambient heating correspond to peak sensor temperatures of 170–300°C. Resistance and giant magneto-resistive (GMR) amplitude of the sensors were measured with time up to 800 hours. Device reliability was predicted from the Arrhenius plots of time to failure (TTF). Microstructure of sensors after stress was studied by scanning transmission electron microscope (STEM) and energy dispersive X-ray spectroscopy (EDX). The device failure mechanism is discussed on the scope of inter-layer diffusion and electromigration.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 563: Symposium M – Materials Reliability in Microelectronics IX , 1999 , 139
Copyright
Copyright © Materials Research Society 1999

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

[1] Dieny, B., Speriosu, V.S., Parkin, S.S.P., Gurney, B.A., Wilhoit, D.R. and Mauri, D., Phys. Rev. B 43, 1297 (1991).Google Scholar
[2] Youssef, J. Ben, Bouziane, K., Koshikina, O., Gall, H. Le, Harfaoui, M. El, Yamani, M. El, Desvignes, J.M. and Fert, A., J. Magn. and Mag. Mater. 165 288 (1997).Google Scholar
[3] Lloyd, J.R. and Clement, J.J., Thin Solid Films 262, 135 (1995).Google Scholar
[4] Kania, H., Kane, J., Yamada, K., Aoshima, K., Kanamine, M., Toda, J.. and Mizoshita, Y., IEEE Trans. Mag. Vol. 33 2872 (1997).Google Scholar
[5] Tanabe, H. and Kitada, M., Defect and diffusion Forum, Vol. 95–98, 271 (1995).Google Scholar
[6] Tsuand, I-Fei Duxstad, K.J., J. Appl. Phys., in press (1999).Google Scholar
[7] Mao, S., Amin, N.. and Murdock, E., J. Appl. Phys. 83 6807 (1998).Google Scholar
[8] Glickman, E. and Nathan, M., J. Appl. Phys. 80(7), 3782 (1996).Google Scholar