Hostname: page-component-77c89778f8-cnmwb Total loading time: 0 Render date: 2024-07-24T02:43:54.560Z Has data issue: false hasContentIssue false
  • English
  • Français

Chemical Analyses of Sol/Gel Surfaces and Thin Films

Published online by Cambridge University Press:  15 February 2011

Carlo G. Pantano ,
C. A. Houser  and
R. K. Brow
Carlo G. Pantano
Affiliation:
Department of Materials Science and Engineering Pennsylvania State University University Park, Pennsylvania 16802, USA
C. A. Houser
Affiliation:
Department of Materials Science and Engineering Pennsylvania State University University Park, Pennsylvania 16802, USA
R. K. Brow
Affiliation:
Department of Materials Science and Engineering Pennsylvania State University University Park, Pennsylvania 16802, USA
Get access

Abstract

The application of surface analysis techniques to the characterization of sol/gel surfaces and thin films is described. Secondary-ion mass spectroscopy (SIMS), x-ray photoelectron spectroscopy (XPS) and sputter-induced photon spectroscopy (SIPS) are used to measure the composition of multicomponent silicate films, the relative water content of alumina films, the nitrogen content of ammonia treated silica films, and the depth profiles for films on black chrome. The determination of chemical structure using XPS and SIMS is also discussed. Finally, a brief introduction to temperature-programmed desorption (TPD) and its potential for studying surface chemical reactions, in situ, is presented.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 32: Symposium B – Better Ceramics Through Chemistry I , 1984 , 255
Copyright
Copyright © Materials Research Society 1984

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Schroeder, H., Oxide Layers Deposited from Organic Solutions, Phys. Thin Films, 5, 7 (1969).Google Scholar
2. Yoldas, B. E. and O'Keefe, T. W., Antireflective Coatings Applied from Metal-Organic Derived Liquid Precursors, Appl. Opt., 18, 3133 (1979).Google Scholar
3. Pantano, C. G., Glaser, P. M. and Armbrust, D. H., Nitridation of Silica Sol/Gel Thin Films in Ultrastructure Processing of Ceramics, Glasses and Composites, Hench, and Ulrich, , Eds., (John Wiley, New York, 1983).Google Scholar
4. Glaser, P. M. and Pantano, C. G., Effect of the H2O/TEOS Ratio Upon the Preparation and Nitridation of Silica Sol/Gel Films, J. Non-Cryst. Sol., 63, 209 (1984).Google Scholar
5. Czanderna, A. W., Editor, Methods of Surface Analysis (Elsevier 1975).Google Scholar
6. Pantano, C. G., Surface and In-Depth Analysis of Glass and Ceramics, Am. Ceram. Soc. Bull., 60 (11), 1154 (1981).Google Scholar
7. Smith, G. and Pantano, C. G., SIMS Studies of Glass Thin Films Prepared with Sol/Gel Techniques, Appl. Surf. Sci., 9 345 (1981).Google Scholar
8. Brinker, C. J. and Mukherjee, S. P., Comparison of Sol-Gel-Derived Thin Films with Monoliths in a Multicomponent Silicate Glass System, Thin Solid Films, 77, 141 (1981).Google Scholar
9. Pettit, R. B. and Brinker, C. J., Sol-Gel Protective Coatings for Black Chrome Solar Selective Films, SPIE, 324, 176 (1982).Google Scholar
10. Brow, R. K. and Pantano, C. G., Composition and Chemical Structure of Nitrided Silica Gel, in this volume.Google Scholar
11. Bach, H., Ion Beam Induced Radiation Applied to Investigations of Thin Surface Layers on Glass Substrates, J. Non-Cryst. Sol., 19, 65 (1975).Google Scholar
12. Tolk, N. H., et al. , In Situ Spectrochemical Analysis of Solid Surfaces by Ion Beam Sputtering, Anal. Chem., 49, 16A (1977).Google Scholar
13. Colton, R. J., Molecular Secondary Ion Mass Spectrometry, J. Vac. Sci. Technol., 18(3), 737 (1981).Google Scholar
14. Benninghoven, A., et al. , Comparative Study of Si(111), Silicon Oxide, SiC, and Si3N4 Surfaces by (SIMS), Thin Solid Films, 28, 59 (1975).Google Scholar
15. Hair, M. L., Hydroxyl Groups on Silica Surfaces, J. Non-Cryst. Sol., 19 (1), 299 (1975).Google Scholar
16. Ohuchi, F. and Chowdry, U., Temperature Programmed Reaction and Desorption Studies on Methanol Oxidation Catalysts, in Proc. 12th No. Am. Thermal Analysis Society Meeting, Williamsburg, VA, 1983.Google Scholar