Hostname: page-component-8448b6f56d-42gr6 Total loading time: 0 Render date: 2024-04-17T21:45:08.341Z Has data issue: false hasContentIssue false

Synthesis of aluminum hydroxide nanoparticles in spontaneously generated vesicles

Published online by Cambridge University Press:  31 January 2011

Iskandar I. Yaacob
Affiliation:
Department of Chemical Engineering, University of Rhode Island, Kingston, Rhode Island 02881-0805
Suhas Bhandarkar
Affiliation:
AT&T Bell Laboratories, 600 Mountain Avenue, Murray Hill, New Jersey 07974
Arijit Bose
Affiliation:
Department of Chemical Engineering, University of Rhode Island, Kingston, Rhode Island 02881-0805
Get access

Abstract

Unilamellar vesicles, formed spontaneously by mixing single-tailed cationic (cetyl trimethyl ammonium tosylate, CTAT) and anionic aqueous solutions of (sodium dodecyl benzene sulfonate, SDBS) surfactants have been used as reactors for the aqueous phase precipitation of nanometer sized particles within their inner cores. AlCl3 solution was encapsulated within these vesicles, aluminum ions were replaced with sodium ions in the extravesicular phase, and sodium hydroxide was then added to the extravesicular region. Hydroxyl ions penetrate through the vesicle walls and react with the available aluminum in the intravesicular region to form the product. The morphology and sizes of these particles were examined by transmission electron microscopy, while their phase and crystalline nature were probed by electron and x-ray diffraction. The product particles were nanometer-sized with near spherical morphology. Good control of particle size was achieved by varying the initial concentration of electrolyte. Single particle electron diffraction revealed a symmetric pair of spots, indicating that the particles were either single crystals or polycrystalline with á low number of grain boundaries or defects. Although wide area electron diffraction showed that the product was δ–Al2O3, powder x-ray diffraction revealed that these particles were, in fact, Al(OH)3. It is likely that heating of these nanoparticles by the high energy electron beam in a high vacuum environment causes a phase transformation, resulting in the difference between the electron and x-ray diffraction results. These results represent the first demonstration of precipitation within vesicles produced spontaneously by mixing appropriate ratios of inexpensive single-tailed surfactants, and may potentially make intravesicular precipitation a commercially viable route for making nanometer-sized particles.

Type
Articles
Copyright
Copyright © Materials Research Society 1993

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Veale, C. R., Fine Powders: Preparation, Properties and Uses (Halsted Press Div., John Wiley & Sons, Inc., New York, 1972).Google Scholar
2Wey, J. S., J. Imag. Sci. 34, 202 (1990).Google Scholar
3Mann, S. and Williams, R.J.P., J. Chem. Soc. Dalton Trans., 311 (1983).Google Scholar
4Mann, S. and Hannington, J. P., J. Colloid Int. Sci. 122, 326 (1988).Google Scholar
5Bhandarkar, S., Yaacob, I., and Bose, A., in Better Ceramics Through Chemistry IV, edited by Zelinski, B. J. J., Brinker, C. J., Clark, D.E., and Ulrich, D.R. (Mater. Res. Soc. Symp. Proc. 180, Pittsburgh, PA, 1990), p. 637.Google Scholar
6Karch, J., Birringer, R., and Gleiter, H., Nature 556, 330 (1987).Google Scholar
7Edelson, L.H. and Glaeser, A.M., J. Am. Ceram. Soc. 71, 225 (1988).Google Scholar
8Matijevic, E., in Ultrastructure Processing of Ceramics and Glasses, edited by Hench, L. L. and Ulrich, D. R. (John Wiley & Sons, New York, 1984), p. 367.Google Scholar
9Siegel, R. W., Mater. Res. Bull. XV, 60 (1990).Google Scholar
10Bhandarkar, S. and Bose, A., J. Colloid Int. Sci. 135, 531 (1990).Google Scholar
11Bhandarkar, S. and Bose, A., J. Colloid Int. Sci. 139, 541 (1990).CrossRefGoogle Scholar
12Liu, H., Graff, G. L., Hyde, M., Sarikaya, M., and Aksay, I. A., in Materials Synthesis Based on Biological Processes, edited by Alper, M., Calvert, P. D., Frankel, R., Rieke, P. C., and Tirrell, D. A. (Mater. Res. Soc. Symp. Proc. 218, Pittsburgh, PA, 1991).Google Scholar
13Kaler, E. W., Murthy, A. K., Rodriguez, B. E., and Zasadzinski, J. A. N., Science 245, 1371 (1989).CrossRefGoogle Scholar
14Yaacob, I., M.S. Thesis (University of Rhode Island, 1992).Google Scholar