Hostname: page-component-76fb5796d-x4r87 Total loading time: 0 Render date: 2024-04-26T05:01:41.433Z Has data issue: false hasContentIssue false
  • English
  • Français

Stability of falling liquid films on flexible substrates

Published online by Cambridge University Press:  13 August 2020

J. Paul Alexander Open the ORCID record for J. Paul Alexander [Opens in a new window] ,
Toby L. Kirk Open the ORCID record for Toby L. Kirk [Opens in a new window]  and
Demetrios T. Papageorgiou Open the ORCID record for Demetrios T. Papageorgiou [Opens in a new window]
J. Paul Alexander
Affiliation:
Department of Mathematics, Imperial College London, LondonSW7 2AZ, UK
Toby L. Kirk
Affiliation:
Mathematical Institute, Oxford University, Woodstock Road, OxfordOX2 6GG, UK
Demetrios T. Papageorgiou*
Affiliation:
Department of Mathematics, Imperial College London, LondonSW7 2AZ, UK
*
†Email address for correspondence: d.papageorgiou@imperial.ac.uk
Get access Rights & Permissions [Opens in a new window]

Abstract

The linear stability of a liquid film falling down an inclined flexible plane under the influence of gravity is investigated using analytical and computational techniques. A general model for the flexible substrate is used leading to a modified Orr–Sommerfeld problem addressed numerically using a Chebyshev tau decomposition. Asymptotic limits of long waves and small Reynolds numbers are addressed analytically and linked to the computations. For long waves, the flexibility has a destabilising effect, where the critical Reynolds number decreases with decreasing stiffness, even destabilising Stokes flow for sufficiently small stiffness. To pursue this further, a Stokes flow approximation was considered, which confirmed the long-wave results, but also revealed a short wave instability not captured by the long-wave expansions. Increasing the surface tension has little effect on these instabilities and so they were characterised as wall modes. Wider exploration revealed mode switching in the dispersion relation, with the wall and surface mode swapping characteristics for higher wavenumbers. The zero-Reynolds-number results demonstrate that the long-wave limit is not sufficient to determine instabilities so the numerical solution for arbitrary wavenumbers was sought. A Chebyshev tau spectral method was implemented and verified against analytical solutions. Short wave wall instabilities persist at larger Reynolds numbers and destabilisation of all Reynolds numbers is achievable by increasing the wall flexibility, however increasing the stiffness reverts back to the rigid wall limit. An energy decomposition analysis is presented and used to identify the salient instability mechanisms and link them to their physical origin.

JFM classification

Interfacial Flows (free surface): Thin films
Type
JFM Papers
Information
Journal of Fluid Mechanics , Volume 900 , 10 October 2020 , A40
Copyright
© The Author(s), 2020. Published by Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Atabek, H. B. & Lew, S. H. 1966 Wave propagation through a viscous incompressible fluid contained in an initially stressed elastic tube. Biophys. J. 6, 481–503.CrossRefGoogle Scholar
Baingne, M. & Sharma, G. 2019 Effect of wall deformability on the stability of surfactant-laden visco-elastic liquid film falling down an inclined plane. J. Non-Newtonian Fluid Mech. 269, 1–16.CrossRefGoogle Scholar
Baingne, M. & Sharma, G. 2020 Effect of wall deformability on the stability of shear-imposed film flow past an inclined plane. Intl J. Engng Sci. 150, 103243.CrossRefGoogle Scholar
Benjamin, T. B. 1957 Wave formation in laminar flow down an inclined plane. J. Fluid Mech. 2, 554–574.CrossRefGoogle Scholar
Benney, D. J. 1966 Long waves on liquid films. J. Math. Phys. 45, 150–155.CrossRefGoogle Scholar
Binny, A. M. 1957 Experiments on the onset of wave formation on a film of water flowing down a vertical plane. J. Fluid Mech. 2, 551–555.CrossRefGoogle Scholar
Carpenter, P. W. & Garrad, A. D. 1985 The hydrodynamic stability of flow over Kramer-type compliant surfaces. Part 1. Tollmien–Schlichting instabilities. J. Fluid Mech. 155, 465–510.CrossRefGoogle Scholar
Chokshi, P. & Kumaran, V. 2008 Weakly nonlinear stability analysis of a flow past a Neo–Hookean solid at arbitrary Reynolds numbers. Phys. Fluids 20, 094109.CrossRefGoogle Scholar
Davies, C. J. & Carpenter, P. W. 1997 Instabilities in a plane channel flow between compliant walls. J. Fluid Mech. 352, 205–243.CrossRefGoogle Scholar
Dawkins, P. T., Dunbar, S. R. & Douglass, R. W. 1998 The origin and nature of spurious eigenvalues in the spectral tau method. J. Comput. Phys. 147, 441–462.CrossRefGoogle Scholar
Dongarra, J. J., Straughan, B. & Walker, D. W. 1996 Chebyshev tau-QZ algorithm methods for calculating spectra of hydrodynamic stability problems. Appl. Numer. Maths 22 (4), 399–434.CrossRefGoogle Scholar
Dragon, C. A. & Grotberg, J. B. 1991 Oscillatory flow and mass transport in a flexible tube. J. Fluid Mech. 231, 135–155.CrossRefGoogle Scholar
Floryan, J. M., Davis, S. H. & Kelly, R. E. 1987 Instabilities of a liquid film flowing down a slightly inclined plane. Phys. Fluids 30, 983–989.CrossRefGoogle Scholar
Gajjar, J. S. B. & Sibanda, P. 1996 The hydrodynamic stability of channel flow with compliant boundaries. Theor. Comput. Fluid Dyn. 8, 105–129.CrossRefGoogle Scholar
Gaurav, & Shankar, V. 2007 Stability of gravity-driven free-surface flow past a deformable solid at zero and finite Reynolds number. Phys. Fluids 19, 024105.CrossRefGoogle Scholar
Gaurav, & Shankar, V. 2010 Role of wall deformability on interfacial instabilities in gravity-driven two-layer flow with a free surface. Phys. Fluids 22, 094103.CrossRefGoogle Scholar
Gkanis, V. & Kumar, S. 2006 Instability of gravity-driven free-surface flow past a deformable elastic solid. Phys. Fluids 18, 044103.CrossRefGoogle Scholar
Halpern, D. & Grotberg, J. B. 1992 Fluid-elastic instabilities of liquid-lined tubes. J. Fluid Mech. 244, 615–632.CrossRefGoogle Scholar
Jain, A. & Shankar, V. 2007 Instability suppression in viscoelastic film flows down an inclined plane lined with a deformable solid layer. Phys. Rev. E 76, 046314.CrossRefGoogle ScholarPubMed
Kalliadasis, S., Ruyer-Quil, C., Scheid, B. & Velarde, M. G. 2012 Falling Liquid Films. Springer.CrossRefGoogle Scholar
Kapitza, P. L. & Kapitza, S. P. 1949 Wave flow of thin viscous liquid films. III. Experimental study of wave regime of a flow. J. Expl Theor. Phys. 19, 105–120.Google Scholar
Kelly, R. E., Goussis, D. A., Lin, S. P. & Hsu, F. K. 1989 The mechanism for surface wave instability in film flow down an inclined plane. Phys. Fluids A 1 (5), 819–828.CrossRefGoogle Scholar
Kramer, M. O. 1957 Boundary-layer stabilisation by distributed damping. J. Aero. Sci. 24, 459.Google Scholar
Landau, L. D. & Lifshitz, E. M. 1986 Theory of Elasticity. Butterworth-Heinemann.Google Scholar
Liu, J., Schneider, J. B. & Gollub, J. P. 1995 Three-dimensional instabilities of film flows. Phys. Fluids 7 (1), 55–67.CrossRefGoogle Scholar
Mandloi, S. & Shankar, V. 2020 Stability of gravity-driven free-surface flow past a deformable solid: the role of depth-dependent modulus. Phys. Rev. E 101, 043107.CrossRefGoogle Scholar
Matar, O. K., Craster, R. V. & Kumar, S. 2007 Falling films on flexible inclines. Phys. Rev. E 76, 056301.CrossRefGoogle ScholarPubMed
Matar, O. K. & Kumar, S. 2004 Rupture of a surfactant-covered thin liquid film on a flexible wall. SIAM J. Appl. Maths 64 (6), 2144–2166.CrossRefGoogle Scholar
Matar, O. K. & Kumar, S. 2007 Dynamics and stability of flow down a flexible incline. J. Engng Maths 57 (2), 145–158.CrossRefGoogle Scholar
McFadden, G. B., Murray, B. T. & Biosvert, R. F. 1990 Elimination of spurious eigenvalues in the Chebyshev tau spectral method. J. Comput. Phys. 91, 228–239.CrossRefGoogle Scholar
Patne, R. & Shankar, V. 2019 Stability of flow through deformable channels and tubes: implications of consistent formulation. J. Fluid Mech. 860, 837–885.CrossRefGoogle Scholar
Peng, J., Jiang, L. Y., Zhuge, W. L. & Zhang, Y. J. 2016 Falling film on a flexible wall in the presence of insoluble surfactant. J. Engng Maths 97, 33–48.CrossRefGoogle Scholar
Peng, J., Zhang, Y. J. & Zhuge, W. L. 2014 Falling film on a flexible wall in the limit of weak viscoelasticity. J. Non-Newtonian Fluid Mech. 210, 85–95.CrossRefGoogle Scholar
Pruessner, L. & Smith, F. T. 2015 Enhanced effects from tiny flexible in-wall blips and shear flow. J. Fluid Mech. 772, 16–41.CrossRefGoogle Scholar
Ruyer-Quil, C. & Manneville, P. 2000 Improved modeling of flows down inclined planes. Eur. Phys. J. B 15, 357–369.CrossRefGoogle Scholar
Sahu, S. & Shankar, V. 2016 Passive manipulation of free-surface instability by deformable solid bilayers. Phys. Rev. E 94, 013111.CrossRefGoogle ScholarPubMed
Shankar, V. & Sahu, A. K. 2006 Suppression of instability in liquid flow down an inclined plane by a deformable solid layer. Phys. Rev. E 73, 016301.CrossRefGoogle ScholarPubMed
Shkadov, V. Y. 1967 Wave flow regimes of a thin layer of a viscous liquid under the action of gravity. Fluid Dyn. 2, 29–34.CrossRefGoogle Scholar
Sisoev, G. M., Matar, O. K., Craster, R. V. & Kumar, S. 2010 Coherent wave structures on falling fluid films flowing down a flexible wall. Chem. Engng Sci. 65, 950–961.CrossRefGoogle Scholar
Sivashinsky, G. I. & Michelson, D. M. 1980 On irregular wavy flow on liquid film down a vertical plane. Prog. Theor. Phys. 63, 2112–2114.CrossRefGoogle Scholar
Thaokar, R. M., Shankar, V. & Kumaran, V. 2001 Effect of tangential interface motion on the viscous instability in fluid flow past flexible surfaces. Eur. Phys. J. B 23, 533–550.CrossRefGoogle Scholar
Tseluiko, D. & Papageorgiou, D. T. 2006 Wave evolution on electrified falling films. J. Fluid Mech. 556, 361–386.CrossRefGoogle Scholar
Whitham, G. B. 1999 Linear and Nonlinear Waves. John Wiley & Sons.CrossRefGoogle Scholar
Yih, C.-S. 1963 Stability of liquid flow down an inclined plane. Phys. Fluids 6 (3), 321–334.CrossRefGoogle Scholar