Hostname: page-component-77c89778f8-gvh9x Total loading time: 0 Render date: 2024-07-16T13:22:00.845Z Has data issue: false hasContentIssue false
  • English
  • Français

Superheating of Metallic Crystals

Published online by Cambridge University Press:  26 February 2011

J. Däges ,
H. Gleiter  and
J. H. Perepezko
J. Däges
Affiliation:
Universität des Saarlandes D-6600 Saarbrücken, West Germany
H. Gleiter
Affiliation:
Universität des Saarlandes D-6600 Saarbrücken, West Germany
J. H. Perepezko
Affiliation:
University of Wisconsin Department of Metallurgical and Mineral Engineering 1509 University Avenue, Madison, WI 53706
Get access

Abstract

For crystals that melt into fluid liquids, superheating of the solid has been detected in only a few cases. In these cases, a crystal was subjected to focused heating in the center. Under a high thermal gradient some interior superheating was possible, but usually only a few degrees or less. A new approach is reported for preparing samples which can exhibit superheating under more uniform thermal conditions. To exclude the vapor from contact with the crystal a continuous coating is developed with a melting temperature in excess of that for the pure core crystal. For single crystal spherical Ag samples with a diameter of about 130 μm the free surface was coated with a continuous higher melting point layer of Au to inhibit surface initiated melting of silver at its melting point. The coated Ag crystals were observed to exhibit superheating of at least 7.5 K above the melting point of pure Ag for time periods of the order of one minute. Under the experimental conditions used, internal stresses could be excluded as the reason for the observed increase in the melting onset temperature of Ag. The superheating duration is related to the interdiffusion between the coating layer and the core crystal. Some microstructural observations and electron microprobe composition scans also relate to the observed superheating behavior. The results seem to disagree with lattice stability models of melting and may open the way to the study of crystals in the metastable superheated state.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 57: Symposium I – Phase Transitions in Condensed Systems--Experiments and Theory , 1985 , 67
Copyright
Copyright © Materials Research Society 1987

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Ainslie, G., MacKenzie, J. D., and Turnbull, D. (1961). J. Chem. Phys. 65, 1718.Google Scholar
Brandes, E. A. (1983). “Smithells Metals Reference Book,” (6th ed.), Butterworths, London.Google Scholar
Cormia, R. L. McKenzie, J. D., and Turnbull, D. (1963). J. Appl.Phys. 34, 2239.Google Scholar
Cotterill, R. M. J., Jensen, E. J., and Kristensen, W. D. (1973). Phys. Letters 44A, 127.CrossRefGoogle Scholar
Gorecki, T. (1974). Z. Metallk. 65, 426.Google Scholar
Hansen, M. and Anderko, K. (1958). “Constitution of Binary Alloys,” (2nd ed.), McGraw-Hill, New York.Google Scholar
Holz, A., and Medeiros, J. F. N. (1978). Phys. Rev. B17, 1161.Google Scholar
Karutz, I. and Stranski, I. N. (1951). Z. Anorg. Allg. Chem. 229, 330.Google Scholar
Kaykin, S. E., and Bennett, H. P. (1939). Dokl. Akad. Nauk. SSSR 23, 31.Google Scholar
Lindemann, F. A. (1910). Z. Physik 11, 609.Google Scholar
Perepezko, J. H. (1984). Mat. Sci. Eng. 65, 125.Google Scholar
Sachs, G., and Werts, J. (1930). Z. Phys. 62, 473.Google Scholar
Turnbull, D. (1950). J. Appl. Phys. 21, 1022.Google Scholar
Turnbull, D. (1956). Solid State Phys. 3, 226–309.Google Scholar
Turnbull, D. (1981). Met. Trans. 12A, 695.Google Scholar
Uhlmann, D. R. (1980). J. Non-Cryst. Sol. 41, 347.Google Scholar
Volmer, M., and Schmidt, O. (1937). Z. Phys. Chem. 35 (8), 467.Google Scholar