Hostname: page-component-848d4c4894-xfwgj Total loading time: 0 Render date: 2024-06-20T08:37:36.588Z Has data issue: false hasContentIssue false

Flow of a concentrated emulsion with surfactant through a periodic porous medium

Published online by Cambridge University Press:  07 December 2022

Alexander Z. Zinchenko*
Affiliation:
Department of Chemical and Biological Engineering, University of Colorado, Boulder, CO 80309-0424, USA
Jacob R. Gissinger
Affiliation:
Department of Chemical and Biological Engineering, University of Colorado, Boulder, CO 80309-0424, USA
Robert H. Davis
Affiliation:
Department of Chemical and Biological Engineering, University of Colorado, Boulder, CO 80309-0424, USA
*
Email address for correspondence: alexander.zinchenko@colorado.edu

Abstract

High-resolution, long-time three-dimensional simulations are presented for slow, pressure-driven flow of a periodic emulsion of deformable drops through a dense, simple cubic array of solid spheres (one drop and one particle per periodic cell). The drops, covered with insoluble, non-diffusive surfactant, are large compared with pores, and they squeeze with high resistance, very closely coating the solids to overcome surface tension and lubrication effects. The solid volume fraction is 50 %, the emulsion concentration $c_{em}$ in the pore space is 36 % or 50 %, the drop-to-medium viscosity ratio $\lambda$ is 0.25 to 4. The contamination measure $\beta \leq 0.1$ keeps the linear surfactant model (assumed in most of the work) physically relevant. The boundary-integral solution requires extreme resolutions (tens of thousands of boundary elements per surface) achieved by multipole acceleration with special desingularizations, combined with flow-biased surfactant transport algorithms for numerical stability. The time-periodic regime is typically attained after a few squeezing cycles; the motion period is used in the extrapolation scheme to evaluate critical capillary numbers $Ca_{crit}$ demarcating squeezing from trapping. Due to Marangoni stresses, even light ($\beta =0.05$) to moderate ($\beta =0.1$) contaminations significantly reduce the average drop-phase migration velocity (up to 2.8 times, compared with clean drops), especially at small $\lambda =0.25$. In contrast, $Ca_{crit}$ is weakly sensitive to contamination and levels off completely at $\beta =0.05$. At $\lambda =0.25$ and $c_{em}=0.36$, the average drop-phase velocities are much different for lightly and moderately contaminated emulsions, except for near-critical squeezing when they become the same. Nonlinear surfactant models (Langmuir, Frumkin) are used to validate the linear model.

Type
JFM Papers
Copyright
© The Author(s), 2022. Published by Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Alpak, F.O., Zacharoudiou, I., Berg, S., Dietderich, J. & Saxena, N. 2019 Direct simulation of pore-scale two-phase visco-capillary flow on large digital rock images using a phase-field lattice Boltzmann method on general-purpose graphics processing units. Comput. Geosci. 23, 849880.CrossRefGoogle Scholar
Avraam, D.G. & Payatakes, A.C. 1995 Flow regimes and relative permeabilities during steady-state two-phase flow in porous media. J. Fluid Mech. 293, 207236.CrossRefGoogle Scholar
Bazhlekov, I.B., Anderson, P.D. & Meijer, H.E.H. 2003 Boundary integral method for deformable interfaces in the presence of insoluble surfactants. In Large-Scale Scientific Computing (ed. I. Lirkov, S. Margenov, J. Waśniewski & P. Yalamov), pp. 355–362. Springer.Google Scholar
Bazhlekov, I.B., Anderson, P.D. & Meijer, H.E.H. 2006 Numerical investigation of the effects of insoluble surfactants on drop deformation and breakup in simple shear flow. J. Colloid Interface Sci. 298, 369394.CrossRefGoogle ScholarPubMed
Borhan, A. & Mao, C.F. 1992 Effect of surfactants on the motion of drops through circular tubes. Phys. Fluids A 4 (12), 26282640.CrossRefGoogle Scholar
Bretherton, F.P. 1961 The motion of long bubbles in tubes. J. Fluid Mech. 10, 166188.CrossRefGoogle Scholar
Crawford, S.C., Bruell, C.J., Ryan, D.K. & Duggan, J.W. 1997 Effects of emulsion viscosity during surfactant-enhanced soil flushing in porous media. Soil Sediment Contam. 6 (4), 355370.CrossRefGoogle Scholar
Cristini, V., Bławzdziewicz, J. & Loewenberg, M. 2001 An adaptive mesh algorithm for evolving surfaces: simulations of drop breakup and coalescence. J. Comput. Phys. 168, 445463.CrossRefGoogle Scholar
Eggleton, C.D., Pawar, Y.P. & Stebe, K.J. 1999 Insoluble surfactants on a drop in an extensional flow: a generalization of the stagnated surface limit to deforming interfaces. J. Fluid Mech. 385, 7999.CrossRefGoogle Scholar
Ferri, J.K. & Stebe, K.J. 1999 Soluble surfactants undergoing surface phase transitions: a Maxwell construction and the dynamic surface tension. J. Colloid Interface Sci. 209, 19.CrossRefGoogle ScholarPubMed
Gissinger, J.R. 2020 Modeling droplets and emulsions with insoluble surfactant flowing through complex environments. PhD thesis, University of Colorado.Google Scholar
Gissinger, J.R., Zinchenko, A.Z. & Davis, R.H. 2019 Drops with insoluble surfactant squeezing through interparticle constrictions. J. Fluid Mech. 878, 324355.CrossRefGoogle Scholar
Gissinger, J.R., Zinchenko, A.Z. & Davis, R.H. 2021 Drop squeezing between arbitrary smooth obstacles. J. Fluid Mech. 908, A33.CrossRefGoogle Scholar
Guido, S. & Preziosi, V. 2010 Droplet deformation under confined Poiseuille flow. Adv. Colloid Interface Sci. 161, 89101.CrossRefGoogle ScholarPubMed
Guillen, V.R., Carvalho, M.S. & Alvarado, V. 2012 Pore scale and macroscopic displacement mechanisms in emulsion flooding. Transp. Porous Med. 94, 197206.CrossRefGoogle Scholar
Hasimoto, H. 1959 On the periodic fundamental solutions of the Stokes equations and their application to viscous flow past a cubic array of spheres. J. Fluid Mech. 5, 317328.CrossRefGoogle Scholar
Hebeker, F.-K. 1986 Efficient boundary element methods for three-dimensional exterior viscous flow. Numer. Meth. Part. D. E. 2, 273297.CrossRefGoogle Scholar
Holbrook, J.A. & Levan, M.D. 1983 Retardation of droplet motion by surfactant. Part 2. Numerical solutions for exterior diffusion, surface diffusion, and adsorption kinetics. Chem. Engng Commun. 20, 273290.Google Scholar
Huerre, A., Theodoly, O., Leshansky, A.M., Valignat, M.-P., Cantat, I. & Jullien, M.-C. 2015 Droplets in microchannels: dynamical properties of the lubrication film. Phys. Rev. Lett. 115, 064501.CrossRefGoogle ScholarPubMed
Janssen, P.J.A. & Anderson, P.D. 2008 Surfactant-covered drops between parallel plates. Chem. Engng Res. Des. 86, 13881396.CrossRefGoogle Scholar
Johnson, R.A. & Borhan, A. 1999 Effect of insoluble surfactants on the pressure-driven motion of a drop in a tube in the limit of high surface coverage. J. Colloid Interface Sci. 218, 184200.CrossRefGoogle Scholar
Johnson, R.A. & Borhan, A. 2003 Pressure-driven motion of surfactant-laden drops through cylindrical capillaries: effect of surfactant solubility. J. Colloid Interface Sci. 261, 529541.CrossRefGoogle ScholarPubMed
Lu, C., Zhao, W., Liu, Y. & Dong, X. 2018 Pore-scale transport mechanisms and macroscopic displacement effects of in-situ oil-in-water emulsions in porous media. J. Energy Resour. Technol. 140 (10), 102904.CrossRefGoogle Scholar
Lin, S.-Y., McKeigue, K. & Maldarelli, C. 1991 Diffusion-limited interpretation of the induction period in the relaxation in surface tension due to the adsorption of straight chain, small polar group surfactant: theory and experiment. Langmuir 7, 10551066.CrossRefGoogle Scholar
Luo, Z.Y., Shang, X.L. & Bai, B.F. 2018 Marangoni effect on the motion of a droplet covered with insoluble surfactant in a square microchannel. Phys. Fluids 30, 077101.CrossRefGoogle Scholar
Luo, Z.Y., Shang, X.L. & Bai, B.F. 2019 Effect of soluble surfactant on the motion of a confined droplet in a square microchannel. Phys. Fluids 31, 117104.Google Scholar
Milliken, W.J. & Leal, L.G. 1994 The influence of surfactant on the deformation and breakup of a viscous drop: the effect of surfactant solubility. J. Colloid Interface Sci. 166, 275285.Google Scholar
Milliken, W.J., Stone, H.A. & Leal, L.G. 1993 The effect of surfactant on the transient motion of Newtonian drops. Phys. Fluids A 5, 6979.CrossRefGoogle Scholar
Mirchi, V., Sabti, M.J., Piri, M. & Goual, L. 2019 Microscale investigation of the impact of surfactant structure on the residual trapping in natural porous media. Ind. Engng Chem. Res. 58, 93979411.CrossRefGoogle Scholar
Muradoglu, M. & Tryggvason, G. 2008 A front-tracking method for computation of interfacial flows with soluble surfactants. J. Comput. Phys. 227, 22382262.CrossRefGoogle Scholar
Muradoglu, M. & Tryggvason, G. 2014 Simulations of soluble surfactants in 3D multiphase flow. J. Comput. Phys. 274, 737757.CrossRefGoogle Scholar
Nemer, M. 2003 Near-contact motion of liquid drops in emulsions and foams. PhD thesis, Yale University.Google Scholar
Nemer, M.B., Chen, X., Papadopoulos, D.H., Bławzdziewicz, J. & Loewenberg, M. 2004 Hindered and enhanced coalescence of drops in Stokes flow. Phys. Rev. Lett. 92, 114501.CrossRefGoogle Scholar
Olbricht, W.L. & Leal, L.G. 1983 The creeping motion of immiscible drops through a converging/diverging tube. J. Fluid Mech. 134, 329355.CrossRefGoogle Scholar
Pawar, Y. & Stebe, K.J. 1996 Marangoni effects on drop deformation in an extensional flow: the role of surfactant physical chemistry. I. Insoluble surfactant. Phys. Fluids 8 (7), 19.CrossRefGoogle Scholar
Ratcliffe, T., Zinchenko, A.Z. & Davis, R.H. 2010 Buoyancy-induced squeezing of a deformable drop through an axisymmetric ring constriction. J. Phys. Fluids 22, 082101.CrossRefGoogle Scholar
Ratcliffe, T., Zinchenko, A.Z. & Davis, R.H. 2012 Simulations of gravity-induced trapping of a deformable drop in a three-dimensional constriction. J. Colloid Interface Sci. 383, 167176.Google Scholar
Smolarkiewicz, P.K. & Szmelter, J. 2005 MPDATA: an edge-based unstructured-grid formulation. J. Comput. Phys. 206 (2), 624649.CrossRefGoogle Scholar
Stone, H.A. 1990 A simple derivation of the time-dependent convective-diffusion equation for surfactant transport along a deforming interface. Phys. Fluids A 2, 111112.CrossRefGoogle Scholar
Stone, H.A. & Leal, L.G. 1990 The effects of surfactants on drop deformation and breakup. J. Fluid Mech. 220, 161186.CrossRefGoogle Scholar
Tryggvason, G., Bunner, B., Esmaeeli, A., Juric, D., Al-rawahi, N., Tauber, W., Han, J., Nas, S. & Jan, Y.-J. 2001 A front-tracking method for the computations of multiphase flow. J. Comput. Phys. 169, 708759.Google Scholar
Velankar, S., Zhou, H., Jeon, H.K. & Macosko, C.W. 2004 CFD evaluation of drop retraction methods for the measurement of interfacial tension of surfactant-laden drops. J. Colloid Interface Sci. 272, 172185.CrossRefGoogle ScholarPubMed
Wang, Y. & Dimitrakopoulos, P. 2012 Low-Reynolds-number droplet motion in a square microfluidic channel. Theor. Comput. Fluid Dyn. 26, 361379.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2000 An efficient algorithm for hydrodynamical interaction of many deformable drops. J. Comput. Phys. 157, 539587.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2002 Shear flow of highly concentrated emulsions of deformable drops by numerical simulations. J.Fluid Mech. 455, 2162.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2006 A boundary-integral study of a drop squeezing through interparticle constrictions. J. Fluid Mech. 564, 227266.Google Scholar
Zinchenko, A.Z. & Davis, R.H. 2008 a Algorithm for direct numerical simulation of emulsion flow through a granular material. J. Comput. Phys. 227, 78417888.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2008 b Squeezing of a periodic emulsion through a cubic lattice of spheres. Phys. Fluids 20, 040803.Google Scholar
Zinchenko, A.Z. & Davis, R.H. 2013 Emulsion flow through a packed bed with multiple drop breakup. J. Fluid Mech. 725, 611663.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2017 a Motion of deformable drops through porous media. Annu. Rev. Fluid Mech. 49 (1), 7190.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2017 b General rheology of highly concentrated emulsions with insoluble surfactant. J. Fluid Mech. 816, 661704.CrossRefGoogle Scholar
Zinchenko, A.Z. & Davis, R.H. 2021 Algorithm for flow of highly-concentrated emulsions through a narrow constriction. J. Comput. Phys. 438, 110363.Google Scholar
Zinchenko, A.Z., Rother, M.A. & Davis, R.H. 1997 A novel boundary-integral algorithm for viscous interaction of deformable drops. Phys. Fluids 9 (6), 14931511.CrossRefGoogle Scholar