Hostname: page-component-7c8c6479df-hgkh8 Total loading time: 0 Render date: 2024-03-29T08:48:11.429Z Has data issue: false hasContentIssue false

Multiscale Computer Simulation of Tensile and Compressive Strain in Polymer-Coated Silica Aerogels

Published online by Cambridge University Press:  31 January 2011

Brian Good*
Affiliation:
Brian.S.Good@nasa.gov, NASA GLenn Research Center, Materials and Structures Division, Cleveland, Ohio, United States
Get access

Abstract

While the low thermal conductivities of silica aerogels have made them of interest to the aerospace community as lightweight thermal insulation, the application of conformal polymer coatings to these gels increases their strength significantly, making them potentially useful as structural materials as well. In this work we perform multiscale computer simulations to investigate the tensile and compressive strain behavior of silica and polymer-coated silica aerogels. Aerogels are made up of clusters of interconnected particles of amorphous silica of less than bulk density. We simulate gel nanostructure using a Diffusion Limited Cluster Aggregation (DLCA) procedure, which produces aggregates that exhibit fractal dimensions similar to those observed in real aerogels. We have previously found that model gels obtained via DLCA exhibited stress-strain curves characteristic of the experimentally observed brittle failure. However, the strain energetics near the expected point of failure were not consistent with such failure. This shortcoming may be due to the fact that the DLCA process produces model gels that are lacking in closed-loop substructures, compared with real gels. Our model gels therefore contain an excess of dangling strands, which tend to unravel under tensile strain, producing non-brittle failure. To address this problem, we have incorporated a modification to the DLCA algorithm that specifically produces closed loops in the model gels. We obtain the strain energetics of interparticle connections via atomistic molecular statics, and abstract the collective energy of the atomic bonds into a Morse potential scaled to describe gel particle interactions. Polymer coatings are similarly described. We apply repeated small uniaxial strains to DLCA clusters, and allow relaxation of the center eighty percent of the cluster between strains. The simulations produce energetics and stress-strain curves for looped and nonlooped clusters, for a variety of densities and interaction parameters.

Type
Research Article
Copyright
Copyright © Materials Research Society 2010

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1 Husing, N. and Schubert, U., Angew. Chem. Int. Ed. 37, 22 (1998).Google Scholar
2 Pierre, A. C. and Pajonk, G. M., Chem. Rev. 2002, 102, 4243 (2002).Google Scholar
3 Rousset, J. L., Boukenter, A., Champagnon, B., Dumas, J., Duval, E., J.F., Quinson and Serughetti, J., J. Phys.: Condens. Matter 2, 8445 (1990).Google Scholar
4 Meador, M. A. B., Fabrizio, E. F., Ilhan, F., Dass, A., Zhang, G., Vassilaras, P., Johnston, J. C. and Leventis, N., Chem. Mater. 17, 1085 (2005).Google Scholar
5 Meakin, P., Phys. Rev. Lett. 51, 1119 (1983).Google Scholar
6 Schaeffer, D. W., Martin, J. E. and Keefer, K. D., Phys. Rev. Lett. 56, 2199 (1986).Google Scholar
7 Freltoft, T., Kjems, J. K. and Sinha, S. K., Phys. Rev. B 33, 269 (1986).Google Scholar
8 Vacher, R., Woignier, T., Pelous, J. and Courtens, E., Phys. Rev. B 37, 6500 (1988).Google Scholar
9 Hasmy, A., Anglaret, E., Foret, M., Pelous, J. and Julien, R., Phys. Rev. B 50, 1305 (1994).Google Scholar
10 , Woignier: Woignier, T. and Phalippou, J., J. Non-Cryst. Solids 93 17 (1987).Google Scholar
11 Ma, H.-S., Jullien, R. and Scherer, G. W., Phys. Rev. E 65, 041403 (2002).Google Scholar
12 Rose, J. H., Ferrante, J. and Smith, J. R., Phys. Rev. Lett. 47, 675 (1981).Google Scholar
13 Meador, M.A.B., Vivod, S. L., McCorkle, L., Quade, D., Sullivan, R. M., Ghosn, L. J., Clark, N. and Capadona, L. A., J. Mater. Chem. 18, 1852 (2008).Google Scholar