Skip to main content Accessibility help
×
Home

Terramechanics-based wheel–terrain interaction model and its applications to off-road wheeled mobile robots

  • Zhenzhong Jia (a1) (a2), William Smith (a1) (a2) and Huei Peng (a1) (a2)

Summary

This paper presents a wheel–terrain interaction model, which enables efficient modeling of wheeled locomotion in soft soil and numerical simulations of off-road mobile robots. This modular model is derived based on wheel kinematics and terramechanics and the main focus is on describing the stress distributions along the wheel–terrain interface and the reaction forces exerted on the wheel by the soil. When the wheels are steered, the shear stresses underneath the wheel were modeled based on isotropic assumptions. The forces and torques contributed by the bulldozing effect of the side surfaces is also considered in the proposed model. Furthermore, the influence of grousers, commonly used on smaller mobile robots, was modeled by (1) averaging the normal pressures contributed by the grousers and the wheel concave portion, and (2) assuming that the shear phenomenon takes places along the grouser tips. By integrating the model with multibody system code for vehicle dynamics, simulation studies of various off-road conditions in three-dimensional environments can be conducted. The model was verified by using field experiment data, both for a single-wheel vehicle and a whole vehicle.

Copyright

Corresponding author

*Corresponding author. E-mail: hpeng@umich.edu

References

Hide All
1.Lagnemma, K. and Dubowsky, S., Mobile Robot in Rough Terrain, Springer Tracts in Advanced Robotics, vol. 12 (Springer, Berlin, 2004).
2.Morales, J. et al. , “Power consumption modeling of skid-steer tracked mobile robots on rigid terrain,” IEEE Trans. Robot. 25 (5), 10981108 (2009).
3.Schäfer, B., Gibbesch, A., Krenn, R. and Rebele, B., “Planetary rover mobility simulation on soft and uneven terrain,” Veh. Syst. Dyn. 48 (1), 149169 (2010).
4.Bekker, M. G., Theory of Land Locomotion (The University of Michigan Press, Ann Arbor, 1956).
5.Bekker, M. G., Introduction to Terrain-Vehicle Systems (The University of Michigan Press, Ann Arbor, 1969).
6.Wong, J. Y., Terramechanics and Off-Road Vehicles (Elsevier, Amsterdam, 1989).
7.Wong, J. Y., Theory of Ground Vehicles, 4th ed. (John Wiley & Sons, Aug. 2008).
8.Wong, J. Y. and Reece, A. R., “Prediction of rigid wheels performance based on analysis of soil-wheel stresses, part I. Performance of driven rigid wheels,” J. Terramechanics 4 (1), 8198 (1967).
9.Wong, J. Y. and Chiang;, C. F.A general theory for skid steering of tracked vehicles on firm ground,” Proc. Inst. Mech. Eng. 215 (3), 343355 (2001).
10.Tran, T. H., Kwok, N. M., Scheding, S. and Ha, Q. P., “Dynamic Modeling of Wheel-Terrain Interaction of a UGV,” Proceedings of the 3rd Annual IEEE Conference on Automation Science and Engineering, Scottsdale, AZ, USA (Sep. 22–25, 2007) pp. 369374.
11.Tran, T. H., “Modeling and Control of Unmanned Ground Vehicles,” Ph.D. Thesis (Sydney, Australia: The Faculty of Engineering, University of Technology, Sep. 2007).
12.Ishigami, G., Miwa, A., Nagatani, K. and Yoshida, K., “Terramechanics-based model for steering maneuver of planetary exploration rovers on loose soil,” J. Field Robot. 24 (3), 233250 (2007).
13.Ishigami, G., “Terramechanics-Based Analysis and Control for Lunar/Planetary Exploration Robots,” Ph.D. Thesis (Sendai, Miyagi, Japan: Department of Aerospace Engineering, Tohoku University, Mar. 2008).
14.Schmid, I. C., “Interaction of vehicle and terrain—Results from 10 years research at IKK,” J. Terramechanics 32 (1), 326 (1995).
15.Harnish, C., Lach, B., Jakobs, R., Troulis, M. and Nehls, O., “A new tyre-soil interaction model for vehicle simulation on deformable ground,” Veh. Syst. Dyn. 43 (1), 384394 (2005).
16.AESCO, Matlab/Simulink Module AS2 TM User's Guide (version 1.12) (2005). http://www.aesco.de/
17.Bauer, R., Leung, W. and Barfoot, T., “Experimental and Simulation Results of Wheel–Soil Interaction for Planetary Rovers,” Proceedings of the IEEE/RSJ International Conference on Intelligent Robots and Systems (IROS), Shaw Conference Center, Edmonton, Alberta, Canada (Aug. 2–6, 2005) pp. 586591.
18.Spong, M. W., Hutchinson, S. and Vidyasagar, M., Robot Modeling and Control (John Wiley & Sons, Nov. 2005).
19.Solis, J. M. and Longoria, R. G.; “Modeling track-terrain interaction for transient robotic vehicle maneuvers,” J. Terramechanics 45 (3), 6578 (2008).
20.Liu, J., Gao, H., Deng, Z. and Tao, J., “Effect of Slip on Tractive Performance of Small Rigid Wheel on Loose Sand”, Proceedings of the 1st International Conference on Intelligent Robotics and Applications (ICIRA '08) (2008).
21.Ding, L., Gao, H., Deng, Z., Yoshida, K. and Nagatani, K., “Slip Ratio for Lugged Wheel of Planetary Rover in Deformable Soil: Definition and Estimation”, Proceedings of the IEEE International Conference on Intelligent Robots and Systems (IROS '09), St. Louis, USA (Oct. 11–15, 2009), pp. 33433348.
22.Ding, L., “Wheel–Soil Interaction Terramechanics for Lunar/Planetary Exploration Rovers: Modeling and Application,” Ph.D. Thesis (Harbin, China: School of Mechatronics Engineering, Harbin Institute of Technology, Dec. 2009).
23.Shibly, H., Iagnemma, K. and Dubowsky, S., “An equivalent soil mechanics formulation for rigid wheels in deformable terrain, with application to planetary exploration rovers,” J. Terramechanics 42 (1), 113 (2005).
24.Ishigmai, G., “Locomotion Mechanics for Planetary Exploration Rovers Based on Steering Characteristics,” Master Thesis (Sendai, Miyagi, Japan: Department of Aerospace Engineering, Tohoku University, Mar. 2005).
25.Ishigami, G., Mizuuchi, K. and Yoshida, K., “Terramechanics-Based Analysis on Locomotion Mechanics of Wheeled Mobile Robots (Part 1. Analysis of Wheel Mechanics on Lunar Regolith Simulant),” Proceedings of the JSME Conference on Robotics and Mechatronics, Kobe, Japan (Jun. 9–11, 2005).

Keywords

Terramechanics-based wheel–terrain interaction model and its applications to off-road wheeled mobile robots

  • Zhenzhong Jia (a1) (a2), William Smith (a1) (a2) and Huei Peng (a1) (a2)

Metrics

Full text views

Total number of HTML views: 0
Total number of PDF views: 0 *
Loading metrics...

Abstract views

Total abstract views: 0 *
Loading metrics...

* Views captured on Cambridge Core between <date>. This data will be updated every 24 hours.

Usage data cannot currently be displayed