Hostname: page-component-848d4c4894-mwx4w Total loading time: 0 Render date: 2024-07-03T07:19:00.659Z Has data issue: false hasContentIssue false

Synthesis of Ultrafine, Multicomponent Particles Using Phospholipid Vesicles

Published online by Cambridge University Press:  15 February 2011

H. Liu
Affiliation:
Department of Materials Science and Engineering, and Advanced Materials Technology Center, Washington Technology Center, University of Washington, Seattle, WA 98195
G. L. Graff
Affiliation:
Department of Materials Science and Engineering, and Advanced Materials Technology Center, Washington Technology Center, University of Washington, Seattle, WA 98195
M. Hyde
Affiliation:
Department of Materials Science and Engineering, and Advanced Materials Technology Center, Washington Technology Center, University of Washington, Seattle, WA 98195
M. Sarikaya
Affiliation:
Department of Materials Science and Engineering, and Advanced Materials Technology Center, Washington Technology Center, University of Washington, Seattle, WA 98195
I. A. Aksay
Affiliation:
Department of Materials Science and Engineering, and Advanced Materials Technology Center, Washington Technology Center, University of Washington, Seattle, WA 98195
Get access

Abstract

Because of their unique properties of self-assembly and selective ion permeability across the lipid bilayers, phospholipid vesicles were used as reaction vessels for the synthesis of ultrafine, multicomponent ceramic particles containing Y, Ba, Cu, and Ag. Chemical inhomogeneities in the system were limited to the individual particle size (< 50 nun), which was a considerable improvement over particles prepared using bulk precipitation routes. The consistent barium deficiency was a serious problem that arose when attempting to control the stoichiometry of the multicomponent system. Our experimental evidence suggests that chemical interactions between the barium cations and the vesicleforming phospholipid may inhibit the precipitation of barium salts. In a parallel study, we performed consolidation studies on vesicle-precipitated Ag2O particles before and after the removal of the phospholipid molecules. Particle packing was greatly improved in the surfactant coated particles. This demonstrates the multifunctionality of this biomimetic system in which the vesicle membrane simultaneously acts as: (i) a reaction cell for particle precipitation, (ii) an ion selective membrane that affects precipitation kinetics, (iii) a barrier to prevent spontaneous agglomeration of the ultrafine particles, and (iv) a lubricant/dispersantth atfacilitatesp article rearrangementd uring consolidation.

Type
Research Article
Copyright
Copyright © Materials Research Society 1991

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Andres, R. P. et al., J. Mater. Res., 4 [3] 704 (1989).Google Scholar
2. Seigel, R. W., Ramasamy, S., Hahn, H., Li, Z., Lu, T., and, Gronsky, R., J. Mater. Res., 3 [6] 1370 (1988).Google Scholar
3. Karck, J., Birringer, R., and Gleiter, H., Nature, 330 [10] 556 (1987).Google Scholar
4. Seigel, R. W., Ramasamy, S., Hahn, H., Li, Z., Lu, T., and Gronsky, R., J, Mater. Res., 3 [6] 1369 (1988).Google Scholar
5. Fendler, J. H., Chem. Rev., 87, 877 (1987).Google Scholar
6. Tarasevich, B. J., Liu, J., Sarikaya, M., and Aksay, I. A., in Better Ceramics Through Chemistry III, MRS Symp. Proc., Vol.121, edited by Brinker, C. J., Clark, D. E., and Ulrich, D. R. (Materials Research Society, Pittsburg, Pennsylvania, 1988), p. 225.Google Scholar
7. Frankel, R. B. and Blakemore, R. P., Phil. Trans. R. Soc. Lond., B304, 567 (1984).Google Scholar
8. Mann, S. and Williams, R. J. P., J. Chem. Soc. Dalton Trans., 311 (1983).Google Scholar
9. Mann, S. and Hannington, J. P., J. Colloid Interface Sci., 122 [2] 326 (1988).Google Scholar
10. Johnson, S. M. and Bangham, A. D., Biochim. Biophys. Acta., 193, 82 (1969).Google Scholar
11. Hauser, H. O., Phillips, M. C., and Stubbs, M., Nature, 239, 342 (1972).Google Scholar
12. Papahadjopoulos, D., Biochim. Biophys. Acta., 241,254 (1971).Google Scholar
13. Bangham, A. D., Standish, M. M., and Watkins, J. C., J. Molec. Biol., 13, 238 (1965).Google Scholar
14. Mann, S., Hannington, J. P., and Williams, R. J. P., Nature, 324, 565 (1986).Google Scholar
15. Fendler, J. H., Membrane Mimetic Chemistry, (Wiley, New York, 1982), p. 113.Google Scholar