Hostname: page-component-7c8c6479df-xxrs7 Total loading time: 0 Render date: 2024-03-30T06:01:23.299Z Has data issue: false hasContentIssue false

Study of Electrical Properties of Microcrystalline Silicon Films Using AC Measurements

Published online by Cambridge University Press:  17 March 2011

Ely A. T. Dirani
Affiliation:
LME, Dept. Eng. de Sistemas Eletronicos, Escola Politécnica da USP, São Paulo,SP, BRAZIL Dept. de Engenharia Elétrica – PUC, São Paulo, SP, BRAZIL
Alexandre M. Nardes
Affiliation:
LME, Dept. Eng. de Sistemas Eletronicos, Escola Politécnica da USP, São Paulo,SP, BRAZIL
Adnei M. Andrade
Affiliation:
LME, Dept. Eng. de Sistemas Eletronicos, Escola Politécnica da USP, São Paulo,SP, BRAZIL
Fernando J. Fonseca
Affiliation:
LME, Dept. Eng. de Sistemas Eletronicos, Escola Politécnica da USP, São Paulo,SP, BRAZIL
Reginaldo Muccillo
Affiliation:
CMDMC, CCTM, IPEN, São Paulo, SP, BRAZIL
Get access

Abstract

Hydrogenated amorphous (a-Si:H) and microcrystalline (µc-Si:H) silicon films are indispensable materials for large area electronic devices like solar cells, image sensors and thin film transistors (TFTs). The interest of the µc-Si:H films arise from the fact that they combine the high optical absorption of a-Si:H and the electrical transport properties close to those of crystalline silicon. In this work we show the correlation between substrate deposition temperature, crystallinity and electrical properties of a-Si:H and µc-Si:H films. The films were prepared by a conventional PECVD (13.56 MHz) RF system from PH3/SiH4/H2 gas mixtures in the temperature range of 100 to 250°C. While phosphorus doped (n) a-Si:H are deposited yielding conductivity values no better than 10−2 S/cm, (n) µc-Si:H layers deposited at substrate temperature of 250°C show conductivity values higher than 101 S/cm, crystalline fraction up to 80% and Hall mobility of about 0.9 cm2. V−1.s−1. It was observed that a change in the dark conductivity behavior occurs around 140°C, with a large increase in the conductivity values. A corresponding increase is not seen in the average grain size and in the crystalline volume fraction, which shows an almost linear increase with the deposition temperature. This stronger influence of the temperature in the electrical characteristics of the µc-Si:H films may be related to the phosphorus activation, which occurs in higher degree at higher deposition temperatures. The correlation among Raman spectroscopy, Hall effect and AC conductivity measurements (frequency range 6 Hz to 13 MHz) shows that the crystalline phase dominates the electrical transport mechanism in µc-Si:H films. Preliminary results of AC measurements indicate that the electrical resistivity of each phase of this material can be determined.

Type
Research Article
Copyright
Copyright © Materials Research Society 2001

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

[1] Tsai, C. C., Amorphous Silicon and Related Materials, edited by Fritzsche, H. (Singapore: World Scientific), 123, 1988.Google Scholar
[2] Komoto, K., Urano, Y., Guizot, J. L., Gangly, G. and Matsuda, A., Jpn. J. Appl. Phys., 29, L1327 (1990)Google Scholar
[3] Shirai, H., Drevillon, D. and Shimizu, I., Jpn. J. Appl. Phys., 33, 5590 (1994).10.1143/JJAP.33.5590Google Scholar
[4] Shanks, H., Fang, C. J., Ley, L., Cardona, M., Demond, F. J. and Kalbitzer, S., Phys. Stat. Sol. B, 100, 43 (1980).Google Scholar
[5] Bottecchia, J. P. and Andrade, A. M. de, Proc. Of 10th Congress of the Brazilian Microelectronic Society, Canela, R. S., Jul. 31- Aug. 4, 439445 (1995).Google Scholar
[6] Veprek, S., Sarot, F. A. and Iqbal, Z., Phys. Rev. B, 36, 3344 (1987).Google Scholar
[7] Zellama, K., Nedialkova, L., Bounouh, Y., Chahed, L., Benlahsen, M., Zeinert, A., Paret, V. and Thèye, M.L., J. of Non-Cryst. Sol., 198–200, 81 (1996).Google Scholar
[8] Davis, E. A., J. of Non-Cryst. Sol., 198–200, 1 (1996).Google Scholar
[9] Matsuda, A., J. of Non-Cryst. Sol., 59–60, 767 (1983).Google Scholar
[10] MacDonald, J. Ross, Impedance Spectroscopy, John Wiley & Sons, New York, 1987.Google Scholar
[11] Pankove, J. I., ed. Hydrogenated amorphous silicon. Orlando, Academic Press, 1984 (Semiconductors and Semimetals, 21, part A, chapt. 14)Google Scholar