Hostname: page-component-8448b6f56d-42gr6 Total loading time: 0 Render date: 2024-04-25T05:10:41.752Z Has data issue: false hasContentIssue false
  • English
  • Français

High Quality RTCVD Sidewall Spacer Dielectrics

Published online by Cambridge University Press:  15 February 2011

D. S. Miles ,
M. R. Mirabedini ,
D. Venables ,
J. J. Wortman  and
D. M. Maher
D. S. Miles
Affiliation:
North Carolina State University, Electrical and Computer Engineering Department
M. R. Mirabedini
Affiliation:
North Carolina State University, Electrical and Computer Engineering Department
D. Venables
Affiliation:
North Carolina State University, Materials Science and Engineering Department, Raleigh, N.C. 27695
J. J. Wortman
Affiliation:
North Carolina State University, Electrical and Computer Engineering Department
D. M. Maher
Affiliation:
North Carolina State University, Materials Science and Engineering Department, Raleigh, N.C. 27695
Get access

Abstract

Rapid thermal chemical vapor deposition (RTCVD) has been investigated as an alternative to low pressure chemical vapor deposition (LPCVD) for formation of sidewall spacer dielectric. Silane (SiH 4 ) and tetraethylorthosilicate (TEOS) were chosen as the silicon gas sources in these studies. Reasonable deposition rates were obtained for RTCVD oxides, oxynitrides and nitrides for use in thin sidewall spacer application. Refractive index and etch rate measurements suggest that oxides deposited with a 2 % flow rate ratio of SiH 4 /N2O and annealed at 900 °C for 10 seconds produces films with excellent structural quality. Refractive index and wet etch rate both exhibit a linear dependence with the gas flow ratio. An increase in deposition pressure decreased the refractive index while increasing the etch rate. Oxide and oxynitride dielectrics formed using SiH 4 had a much superior step coverage over a wide range of aspect ratios than TEOS dielectrics. Dit and breakdown fields for oxides and oxynitrides with 3 atomic % nitrogen were comparable to that of thermal oxide indicating their good electrical quality. The results reported suggest that RTCVD sidewall spacers are a promising candidate for use in future MOSFET devices.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 387: Symposium P – Rapid Thermal and Integrated Processing IV , 1995 , 277
Copyright
Copyright © Materials Research Society 1995

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1. Sangiorgi, E., Pinto, M., Venturi, F. and Fichtner, W., IEEE Electron Device Lett. EDL–9, 13 (1988).Google Scholar
2. Toyoshima, Y., Nihira, H., Wada, M. and Kanzaki, K., IEDM Tech. Digest, 786 (1984).Google Scholar
3. Toyoshima, Y., Iwai, H., Matsuoka, F., Hayashida, H., Maeguchi, K. and Kanzaki, K., IEEE Trans. Electron Devices, 37 (6), 1496–1503 (1990).Google Scholar
4. Mazuré, C., Gunderson, C. and Roman, B., IEDM, 893 (1992).Google Scholar
5. Kusunoki, S., Inuishi, M., Yamaguchi, T., Tsukamoto, K. and Akasaka, Y., IEDM, 649 (1991).Google Scholar
6. Mizuno, T., Sawada, S., Saitoh, Y. and Tanaka, T., IEEE Trans. Electron Devices, 38 (3), 584 (1991).Google Scholar
7. Xu, X-L., Kuehn, R. T., Wortman, J. J. and Öztürk, M. C., Appl. Phys. Lett., 60 (24), 3063 (1992).Google Scholar
8. Misra, V., Xu, X-L. and Wortman, J. J., Mat. Res. Soc. Symp. Proc., 342, 187 (1994).Google Scholar
9. Chapman, D. T., Melzak, J. M., Fordham, M. J., Wortman, J. J., Özttürk, M. C. and Sorrell, F. Y., Ext. Abs. 179th Electrochem. Soc. Mtg., Washington, D.C., (358), 541–543 (1991).Google Scholar
10. Ren, X., Öztürk, M. C. and Wortman, J. J., J. Vac. Sci. Technol. B, 10 (3), 1081–85 (1992).Google Scholar
11. Miles, D. S., Harris, G. S., Venables, D., Mirabedini, M. R., Wortman, J. J., Maher, D. M. and Hauser, J. R., Mat. Res. Soc. Symp. Proc., 338, 43–49 (1994).Google Scholar
12. Levin, R. M. and Evans-Lutterodt, K., J. Vac. Sci. Technol. B 1, 54–61 (1983).Google Scholar
13. Xu, X-L., McLarty, P. K., Brush, H., Misra, V. and Wortman, J. J., J. Electrochem. Soc., 140 (10), 2970 (1993).Google Scholar
14. Hill, W. L. II, Master of Science Degree Thesis, North Carolina State University, (1994).Google Scholar