Skip to main content Accessibility help

Thermoelectric properties of Ca3Co4O9 and Ca2.8Bi0.2Co4O9 thin films in their island formation mode

  • Priyanka Jood (a1), Germanas Peleckis (a1), Xiaolin Wang (a1) and Shi Xue Dou (a1)


Ca3Co4O9 and Ca2.8Bi0.2Co4O9 thin films were fabricated on LaAlO3 (LAO) substrate using pulsed laser deposition technique and were studied for their thermoelectric (TE) properties in Stranski–Krastanov mode for the first time. The thin films consisted of 3D clusters/islands on a ∼14-nm thick 2D layer with cluster density being higher for Ca2.8Bi0.2Co4O9 thin films. The clusters also represent areas of dislocation and therefore act as carrier scattering centers, which leads to a temperature-activated type conductivity. Seebeck coefficient as high as 136 and 163 μ V/K was measured for the Ca3Co4O9 and Ca2.8Bi0.2Co4O9 thin films, respectively, which is among the highest reported values for this system. The 3D island formation was also found to be useful in reducing the thermal conductivity of the thin film/substrate system by increased phonon scattering. This work shows that the island formation in thin films can be utilized as a means of enhancing TE properties of a thin film system, however, a detailed work including optimization of the film thickness and cluster/inland density is required.


Corresponding author

a) Address all correspondence to this author. e-mail:,


Hide All
1. Shikano, M. and Funahashi, R.: Electrical and thermal properties of single-crystalline (Ca2CoO3)0.7CoO2 with a Ca3Co4O9 structure. Appl. Phys. Lett. 82, 1851 (2003).
2. Yang, W., Yu, S., Jinguang, C., Xianjie, W., and Wenhui, S.: The thermal-transport properties of the Ca3−xAgxCo4O9 system (0≤x≤0.3). J. Phys. Condens. Matter 19, 356216 (2007).
3. Xu, G., Funahashi, R., Shikano, M., Matsubara, I., and Zhou, Y.: Thermoelectric properties of the Bi- and Na-substituted Ca3Co4O9 system. Appl. Phys. Lett. 80, 3760 (2002).
4. Mikami, M., Ando, N., Guilmeau, E., and Funahashi, R.: Effect of Bi substitution on microstructure and thermoelectric properties of polycrystalline [Ca2CoO3]pCoO2 . Jpn. J. Appl. Phys., Part 1 45, 4152 (2006).
5. Liu, Y., Lin, Y., Jiang, L., Nan, C-W., and Shen, Z.: Thermoelectric properties of Bi3+ substituted Co-based misfit-layered oxides. J. Electroceram. 21, 748 (2008).
6. Zhang, Y., Zhang, J., and Lu, Q.: Synthesis of highly textured Ca3Co4O9 ceramics by spark plasma sintering. Ceram. Int. 33, 1305 (2007).
7. Zhou, Y., Matsubara, I., Horii, S., Takeuchi, T., Funahashi, R., Shikano, M., Shimoyama, J-I., Kishio, K., Shin, W., Izu, N., and Murayama, N.: Thermoelectric properties of highly grain-aligned and densified Co-based oxide ceramics. J. Appl. Phys. 93, 2653 (2003).
8. Prevel, M., Lemonnier, S., Klein, Y., Hebert, S., Chateigner, D., Ouladdiaf, B., and Noudem, J.G.: Textured Ca3Co4O9 thermoelectric oxides by thermoforging process. J. Appl. Phys. 98, 093706 (2005).
9. Qiao, Q., Gulec, A., Paulauskas, T., Kolesnik, S., Dabrowski, B., Ozdemir, M., Boyraz, C., Mazumdar, D., Gupta, A., and Klie, R.F.: Effect of substrate on the atomic structure and physical properties of thermoelectric Ca3Co4O9 thin films. J. Phys. Condens. Matter 23, 305005 (2011).
10. Sun, T., Hng, H.H., Yan, Q., and Ma, J.: Effects of pulsed laser deposition conditions on the microstructure of Ca3Co4O9 thin films. J. Electron. Mater. 39, 1611 (2010).
11. Sakai, A., Kanno, T., Yotsushashi, S., Odagawa, A., and Adachi, H.: Control of epitaxial growth orientation and anisotropic thermoelectric properties of misfit-type Ca3Co4O9 thin films. Jpn. J. Appl. Phys. 44, L966 (2005).
12. Sugiura, K., Ohta, H., Nomura, K., Hirano, M., Hosono, H., and Koumoto, K.: High electrical conductivity of layered cobalt oxide Ca3Co4O9 epitaxial films grown by topotactic ion-exchange method. Appl. Phys. Lett. 89, 032111 (2006).
13. Hicks, L.D. and Dresselhaus, M.S.: Effect of quantum-well structures on the thermoelectric figure of merit. Phys. Rev. B 47, 12727 (1993).
14. Mikami, M., Chong, K., Miyazaki, Y., Kajitani, T., Inoue, T., Sodeoka, S., and Funahashi, R.: Bi-substitution effects on crystal structure and thermoelectric properties of Ca3Co4O9 single crystals. Jpn. J. Appl. Phys. 45, 4131 (2006).
15. Sun, T., Hng, H.H., Yan, Q.Y., and Ma, J.: Enhanced high temperature thermoelectric properties of Bi-doped c-axis oriented Ca3Co4O9 thin films by pulsed laser deposition. J. Appl. Phys. 108, 083709 (2010).
16. Zhou, Y., Matsubara, I., Shin, W., Izu, N., and Murayama, N.: Effect of grain size on electric resistivity and thermopower of (Ca2.6Bi0.4)Co4O9 thin films. J. Appl. Phys. 95, 625 (2004).
17. Ohtake, M., Nukaga, Y., Kirino, F., and Futamoto, M.: Effects of substrate temperature and Cu underlayer thickness on the formation of SmCo5(0001) epitaxial thin films. J. Appl. Phys. 107, 09A706 (2010).
18. Sathyamoorthy, R., Narayandaas, S.K., and Mangalaraj, D.: Effect of substrate temperature on the structure and optical properties of CdTe thin film. Sol. Energy Mater. Sol. Cells 76, 339 (2003).
19. Zhang, Y.F., Zhang, J.X., Lu, Q.M., and Zhang, Q.Y.: Synthesis and characterization of Ca3Co4O9 nanoparticles by citrate sol-gel method. Mater. Lett. 60, 2443 (2006).
20. Gilmer, G.H., Huang, H., and Roland, C.: Thin film deposition: Fundamentals and modeling. Comp. Mater. Sci. 12, 354 (1998).
21. Cieniek, L. and Kac, S.: Influence of Ca content on the structure and properties οf (Co, Ca)O thin films deposited by PLD technique. Acta Phys. Pol. A 117, 803 (2010).
22. Hu, Y.F., Si, W.D., Sutter, E., and Li, Q.: In situ growth of c-axis oriented Ca3Co4O9 thin films on Si (100). Appl. Phys. Lett. 86, 082103 (2005).
23. Chang, C.C., Wu, X.D., Ramesh, R., Xi, X.X., Ravi, T.S., Venkatesan, T., Hwang, D.M., Muenchausen, R.E., Foltyn, S., and Nogar, N.S.: Origin of surface roughness for c-axis oriented Y-Ba-Cu-O superconducting films. Appl. Phys. Lett. 57, 1814 (1990).
24. Hafez, M.A., Elamrawi, K.A., and Elsayed-Ali, H.E.: Pulsed laser deposition of InP thin films on sapphire(1 0 0 0) and GaAs(1 0 0). Appl. Surf. Sci. 233, 42 (2004).
25. Ohta, H., Sugiura, K., and Koumoto, K.: Recent progress in oxide thermoelectric materials: p-type Ca3Co4O9 and n-type SrTiO3 . Inorg. Chem. 47, 8429 (2008).
26. Sun, T., Ma, J., Yan, Q.Y., Huang, Y.Z., Wang, J.L., and Hng, H.H.: Influence of pulsed laser deposition rate on the microstructure and thermoelectric properties of Ca3Co4O9 thin films. J. Cryst. Growth 311, 4123 (2009).
27. Kanno, T., Yotsuhashi, S., and Adachi, H.: Anisotropic thermoelectric properties in layered cobaltite AxCoO2 (A = Sr and Ca) thin films. Appl. Phys. Lett. 85, 739 (2004).
28. Hughes, R.C.: Time-resolved hole transport in a-SiO2 . Phys. Rev. B 15, 2012 (1977).
29. Heremans, J.P., Thrush, C.M., and Morelli, D.T.: Thermopower enhancement in PbTe with Pb precipitates. J. Appl. Phys. 98, 063703 (2005).
30. Rogacheva, E.I., Nashchekina, O.N., Vekhov, Y.O., Dresselhaus, M.S., and Cronin, S.B.: Effect of thickness on the thermoelectric properties of PbS thin films. Thin Solid Films 423, 115 (2003).



Full text views

Total number of HTML views: 0
Total number of PDF views: 0 *
Loading metrics...

Abstract views

Total abstract views: 0 *
Loading metrics...

* Views captured on Cambridge Core between <date>. This data will be updated every 24 hours.

Usage data cannot currently be displayed