Hostname: page-component-76fb5796d-zzh7m Total loading time: 0 Render date: 2024-04-25T11:37:31.349Z Has data issue: false hasContentIssue false

Growth of zirconia particles by heterocoagulation, self-assembly, and convection-induced coagulation during forced hydrolysis in a refluxed reaction vessel

Published online by Cambridge University Press:  31 January 2011

Yu-Chen Chang*
Affiliation:
Department of Chemical Engineering and Materials Science, Yuan Ze University, Chungli, Taiwan, Republic of China
Kuei-Yuan Cheng
Affiliation:
Department of Chemical Engineering and Materials Science, Yuan Ze University, Chungli, Taiwan, Republic of China
*
a) Address all correspondence to this author. e-mail: ycchang@saturn.yzu.edu.tw
Get access

Abstract

In literature related to forced hydrolysis of zirconia, heterocoagulation between large particulates and primary crystallites is generally accepted as the principal route of growth. Our dynamic light scattering (DLS) results revealed an S-shaped growth curve with the growth rate (slope) varying notably from one stage to the other, implying that other coagulation mechanisms may be present. Time-sequenced side-by-side electron microscopy and DLS analyses were conducted along the curves alongside with field emission scanning electron microscopy of full-grown particles. We find that particles growth follows a two-stage heterocoagulation process with primary crystallites and small particles produced from the first-stage serving as building blocks for the first and second stages, respectively. It interesting to note that growth during the second stage occurs by self-assembly and a hypothesis is proposed. Convection-induced coagulation leads to enhanced particle growth for a low precursor concentration but minimal growth for a higher one, both of which conform to the predictions of Melis et al. [AIChE J. 45, 1383 (1999)].

Type
Articles
Copyright
Copyright © Materials Research Society 2009

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1Clearfield, A. and Vaughan, P.A.: The crystal structure of zirconyl chloride octahydrate and zirconyl bromide octahydrate. Acta Crystallogr. 9, 555 (1956).Google Scholar
2Fryer, J.R.Hutchison, J.L. and Paterson, R.: An electron microscopic study of the hydrolysis products of zirconyl chloride. J. Colloid Interface Sci. 34, 238 (1970).Google Scholar
3Singhal, A.Toth, L.M.Lin, J-S., and Affholter, K.: Zirconium(IV) tetramer/octamer hydrolysis equilibrium in aqueous hydrochloric acid solution. J. Am. Chem. Soc. 118, 11529 (1996).Google Scholar
4Matsui, K.Suzuki, H. and Ohgai, M.: Raman spectroscopic studies on the formation mechanism of hydrous-zirconia fine particles. J. Am. Ceram. Soc. 78, 146 (1995).Google Scholar
5Hu, M.Z-C., Harris, M.T. and Byers, C.H.: Nucleation and growth for synthesis of nanometric zirconia particles by forced hydro-lysis. J. Colloid Interface Sci. 198, 87 (1998).CrossRefGoogle Scholar
6Matsui, K. and Ohgai, M.: Formation mechanism of hydrous zirconia particles produced by the hydrolysis of ZrOCl2 solutions: III, Kinetics study for the nucleation and crystal-growth processes of primary particles. J. Am. Ceram. Soc. 84, 2303 (2001).Google Scholar
7Hu, M.Z-C., Hunt, R.D.Payzant, E.A. and Hubbard, C.R.: Nanocrystallization and phase transformation in monodispersed ultra-fine zirconia particles from various homogeneous precipitation methods. J. Am. Ceram. Soc. 82, 2313 (1999).Google Scholar
8Jakubus, P.Adamski, A.Kurzawa, M. and Sojka, Z.: Texture of zirconia obtained by forced hydrolysis of ZrOCl2 solution-Influence of aging on thermal behavior. J. Therm. Anal. Calorim. 72, 299 (2003).CrossRefGoogle Scholar
9Clearfield, A.: Structural aspects of zirconium chemistry. Rev. Pure & Appl. Chem. 14, 91 (1964).Google Scholar
10Hu, M.Z-C., Zielke, J.T.Lin, J-S., and Byers, C.H.: Small-angle x-ray scattering studies of early-stage colloid formation by thermohydrolytic polymerization of aqueous zirconyl salt solutions. J. Mater. Res. 14, 103 (1999).Google Scholar
11Singhal, A.Toth, L.M.Beaucage, G.Lin, J-S., and Peterson, J.: Growth and structure of zirconium hydrous polymers in aqueous solutions. J. Colloid Interface Sci. 194, 470 (1997).Google Scholar
12Matsui, K. and Ohgai, M.: Formation mechanism of hydro-zirconia particles produced by hydrolysis of ZrOCl2 solution. J. Am. Ceram. Soc. 80, 1949 (1997).Google Scholar
13Hogg, R.Healy, T.W. and Fuerstenau, D.W.: Mutual coagulation of colloidal dispersions. Trans. Faraday Soc. 62, 1638 (1966).Google Scholar
14Israelachvili, J.N.: Intermolecular and Surface Forces (Academic Press, London, England, 1985).Google Scholar
15Melis, S.Verduyn, M.Storti, G.Morbidelli, M. and Baldyga, J.: Effect of fluid motion on the aggregation of small particles subject to interaction forces. AIChE J. 45, 1383 (1999).Google Scholar
16Smoluchowski, M.: Study of a mathematical theory of the coagulation kinetics of colloidal solutions. Z. Phys. Chem. 92, 129 (1917).Google Scholar
17Verwey, E.J.W. and Overbeek, J.T.G.: Theory of the Stability of Lyophobic Colloids (Elsevier, Amsterdam, Holland, 1948).Google Scholar
18Spielman, L.A.: Viscous interactions in Brownian coagulation. J. Colloid Interface Sci. 33, 562 (1970).Google Scholar
19Grübel, G., Abernathy, D.L.Riese, D.O.Vos, W.L. and Wegdam, G.H.: Dynamics of dense, charge-stabilized suspensions of colloidal silica studied by correlation spectroscopy with coherent x-rays. J. Appl. Cryst. 33, 424 (2000).Google Scholar
20Cundy, C.S. and Cox, P.A.: The hydrothermal synthesis of zeolites: Precursors, intermediates and reaction mechanism. Micro-porous Mesoporous Mater. 82, 1 (2005).Google Scholar
21Biswas, K.Das, B. and C.Rao, N.R.: Growth kinetics of ZnO nanorods: Capping-dependent mechanism and other interesting features. J. Phys. Chem. C 112,(7) 2404 (2008).CrossRefGoogle Scholar